Invacare IOH200AW Manuale utente

User: Before using the product, read this manual

and save for future reference.

Supplier:

This manual must be given to the end user.

For more information regarding

Invacare products, parts, and services,

please visit www.invacare.eu.com

Operator Manual

HomeFill

®

II Compressor

Model IOH200AW

English UK. . . . . . . . . . . . . . 2

Dutch . . . . . . . . . . . . . . . . 39

French . . . . . . . . . . . . . . . . 77

Greek . . . . . . . . . . . . . . . 120

Italian. . . . . . . . . . . . . . . . 163

Portuguese . . . . . . . . . . . 206

Spanish . . . . . . . . . . . . . . 246

0434

WARNING

HomeFill

®

II Compressor 2 Part No 1145805

 WARNING

DO NOT OPERATE THIS EQUIPMENT WITHOUT

FIRST READING AND UNDERSTANDING THIS

MANUAL. IF YOU ARE UNABLE TO

UNDERSTAND THE DANGERS, WARNINGS,

CAUTIONS, AND INSTRUCTIONS, CONTACT

INVACARE TECHNICAL SERVICES BEFORE

ATTEMPTING TO USE THIS EQUIPMENT -

OTHERWISE, SERIOUS INJURY OR PROPERTY

DAMAGE MAY RESULT.

 DANGER

Users MUST NOT SMOKE while using this device. Do not

keep matches, lit cigarettes or other sources of ignition in

the same room as this product. Textiles and other

materials which would are not normally flammable are

easily ignited and burn with great intensity in oxygen

enriched air. Failure to observe this warning can result in

severe fire, property damage and cause physical injury or

DEATH.

NOTE: Updated versions of this manual are available at

www.invacare.com.

TABLE OF CONTENTS

Part No 1145805 3 HomeFill

®

II Compressor

SPECIAL NOTES ...............................................4

TYPICAL PRODUCT PARAMETERS ...................6

LABEL LOCATION ............................................8

DEALER INFORMATION ...................................9

HOMEFILL II INFORMATION ........................... 10

SECTION 1—GENERAL GUIDELINES ................ 11

SECTION 2—INITIAL SETUP ........................... 15

Initial Set Up of Compressor ........................................................15

SECTION 3—CHECKLIST AND CYLINDER

INSPECTION.................................................. 19

Compressor Operation Checklist ...............................................19

Cylinder Prefill Inspection ..............................................................19

SECTION 4—COMPRESSOR OPERATION.......... 22

Connecting/Disconnecting the Cylinder to/from the

Compressor ......................................................................................22

Turning the Compressor On ........................................................27

Setting the Flow Knob to the Prescribed Setting .....................28

Technical Description .....................................................................29

SECTION 5—INDICATOR LIGHTS.................... 31

SECTION 6—TROUBLESHOOTING/ CYLINDER FILL

TIMES ........................................................... 33

SECTION 7—MAINTENANCE.......................... 36

Cleaning the Compressor Filter ...................................................36

Cabinet ...............................................................................................37

HomeFill

®

II Compressor 4 Part No 1145805

SPECIAL NOTES

Check all parts for shipping damage. In the event of damage,

DO NOT use. Contact Invacare for further instruction.

Signal words are used throughout this manual and apply to

hazards or unsafe practices which could result in personal

injury or property damage. Refer to the following table for

definitions of the signal words.

ACCESSORIES

Many different types of humidifiers, oxygen tubing, cannulas

and masks can be used in conjunction with this device. You

should contact your local home care provider for advice on

which of these devices is most suitable for you. Your home

care provider can also provide advice on proper usage,

maintenance, and cleaning.

 WARNING

Invacare products are specifically designed and

manufactured for use in conjunction with Invacare

accessories. Accessories designed by other manufacturers

have not been tested by Invacare and are not

recommended for use with Invacare products.

SIGNAL WORD MEANING

DANGER Danger indicates an imminently hazardous

situation which, if not avoided, will result in

death or serious injury.

WARNING Warning indicates a potentially hazardous

situation which, if not avoided, could result

in death or serious injury.

CAUTION Caution indicates a potentially hazardous

situation which, if not avoided, could result

in property damage.

Part No 1145805 5 HomeFill

®

II Compressor

RECYCLING INFORMATION

This product is supplied by an environmentally aware

manufacturer which adheres to the Waste Electrical and

Electronic Equipment (WEEE) Directive 2002/96/CE.

This product may contain substances that could be harmful to

the environment if disposed of in places (landfills) which are

not deemed appropriate by current legislation.

A 'crossed out wheelie bin' symbol has been placed on this

product to encourage you to recycle wherever possible.

Please be environmentally responsible and recycle this product

through your recycling facility at the end of it useful life.

HomeFill

®

II Compressor 6 Part No 1145805

TYPICAL PRODUCT

PARAMETERS

TYPICAL PRODUCT PARAMETERS

- COMPRESSOR

Regulatory Listing: EN/IEC 60601-1-2 EMC

Alternating Current

Type BF equipment

Unit running

Unit not running

Attention - Consider Accompanying Documents

DO NOT smoke

Class II, Double Insulation

This product complies with Directive 93/42/EEC

concerning medical devices.

The launch date of this product is stated in the CE

declaration of conformity.

Operating temperature:

50 to 95° F (10 to 35° C) @ 20 to 60%

non-condensing humidity

Storage temperature:

-10 to 150° F (-23 to 65° C) @ 15 to 95%

humidity

Input Pressure Required:

14 - 21 PSI (96.5-144.7 kPa)

Input Flow Required:

2 L/min

Input O2% Required:

>90% O

2

Width:

20 ¼ inches (51.44 cm)

Height:

15 inches (38.1 cm)

Part No 1145805 7 HomeFill

®

II Compressor

CONSERVER/REGULATOR

SPECIFICATIONS

Depth:

16 inches (40.64 cm)

Weight:

33 lbs (14.97 kg)

Shipping Weight:

39 lbs (17.69 kg)

Oxygen Output

Settings 1 - 5 L/min pulse

2 L/min. continuous

HomeFill

®

II Compressor 8 Part No 1145805

LABEL LOCATION

DANGER - RISK OF ELECTRIC SHOCK

DO NOT remove cover. Refer servicing to qualified

service personnel.

DANGER- RISK OF FIRE

NO SMOKING - Keep ALL sources of ignition out

of the room in which this product is located and

away from areas where oxygen is being delivered.

Textiles, oil and other combustibles are easily

ignited and will burn with great intensity in oxygen

enriched air.

P/N 1145730 Rev A - 4/18/07

WARNING

Keep all connections free of oil and grease. See Owner’s

Manual before cleaning. NEVER oil or lubricate coupling.

Cylinders filled on this unit MUST be labeled “Contents

of this cylinder are the product of an oxygen

concentrator.”

Keep all connections free of oil and grease to avoid

violent ignition. See Owner’s Manual before cleaning.

This unit contains moving and high pressure

components. Manufacturer Service Only.

BEFORE COUPLING CYLINDER,

PUSH DOWN ON SLEEVE UNTIL

GREEN DOTS ARE VISIBLE.

Serial Number

Label Location

Specification

Label Location

P/N 1048080 Rev A -4/11/07

Part No 1145805 9 HomeFill

®

II Compressor

DEALER INFORMATION

NOTE: Invacare recommends leaving a full cylinder of oxygen with

the patient after setting up the HomeFill II compressor.

Before leaving a HomeFill II Compressor with a user, the

following checklist MUST be completed:

❑ Make sure the pressure test on cylinder has not expired.

❑ Instruct the user on the safe operation of the concentrator

and review all warnings.

❑ Instruct the user on the safe operation of the HomeFill II

compressor and review all warnings.

❑ Leave a full cylinder of oxygen with the user.

❑ Leave a copy of all warnings and filling instructions with

the user.

HomeFill

®

II Compressor 10 Part No 1145805

HOMEFILL II INFORMATION

HomeFill II is an accessory device to the oxygen concentrator,

which enables the patient to refill custom portable oxygen

cylinders for personal use.

NOTICE

The HomeFill II compressor is for use with specially

designed Invacare Platinum™5 and Platinum 9 HomeFill

II compatible oxygen concentrators.

The oxygen concentrator can be set to maximum flow

rate of when operating with HomeFill II compressor:

Platinum 5 - 2.5 L/min. or less

Platinum 9 - 5 L/min. or less

To determine if your oxygen concentrator is HomeFill II

compatible, examine the lower right corner of the rear of

the oxygen concentrator for an outlet fitting and refer to

the illustration below.

TOP VIEW

Concentrator

Power Cord

Outlet Fitting

Part No 1145805 11 HomeFill

®

II Compressor

SECTION 1—GENERAL GUIDELINES

 WARNING

SECTION 1 - GENERAL GUIDELINES contains

important information for the safe operation and use of

this product. DO NOT use this product or any available

optional equipment without first reading and fully

understanding these instructions and any additional

instructional material such as Owner’s Manuals, Service

Manuals or Instruction Sheets supplied with this product

or optional equipment. If you are unable to understand

the Warnings, Cautions or Instructions, contact a health

care professional, dealer or technician before attempting

to use this equipment - otherwise, injury or damage may

occur.

In order to ensure the safe installation, assembly and

operation of the HomeFill II Compressor these instructions

MUST be followed.

“Caution: Statutory law can restrict this device to sale by or on

order of a doctor, or any other practitioner licensed by the law

of the governmental agency in which he/she practices to use

or order the use of this device.”

 WARNING

This device is for the sole use of the oxygen patient. Cylinders

MUST ONLY be used by the oxygen patient and may not to be

distributed to any other individual for any purpose.

The maximum patient flow while filling the cylinders with

the IOH200AW is 2.5 L/min. for Platinum 5 and 5 L/min. for

Platinum 9.Patients with a higher prescribed flow should not

transfill while receiving supplemental oxygen treatment from

the Platinum Concentrator.

HomeFill

®

II Compressor 12 Part No 1145805

 WARNING (CONTINUED)

NEVER block product air openings or place the product on a

soft surface, such as a bed or couch, where the air opening

may be blocked. Keep the openings free from lint, hair and the

like.

DO NOT use outdoors.

NEVER use near any type of flame or flammable/explosive

substance, vapour or atmosphere.

DO NOT disassemble. The unit is provided with double

insulation and has no serviceable parts. Should any service be

required, contact Invacare Technical Service.

If the compressor has a damaged cord or plug, if it is not

working properly, if it has been dropped or damaged, or

immersed in water, please call a qualified technician for

inspection and repair.

If any leakage of the oxygen cylinder is detected DO NOT

attempt to use the cylinder. Turn the flow selector knob on the

regulator to “Off”. If leakage persists, place the cylinder

outdoors and notify your Home Health Care Provider or

Service Representative of this condition.

DO NOT allow oil from your hands or other sources to come

into contact with the compressor coupling or bottle fittings. In

the presence of oxygen, these substances may become

flammable and may cause injury. Avoid touching the bottle

fitting whenever possible. Some examples of items to be

avoided are hand creams and lotions, cooking oils, suntan oils

or sunblocks and similar oil-based products. If you use these

types of products Invacare suggests you wash your hands

prior to using the HomeFill unit. Should the bottle fitting

come into contact with any such substance it should be wiped

with a damp cloth prior to being connected to the compressor.

Part No 1145805 13 HomeFill

®

II Compressor

 WARNING (CONTINUED)

NEVER oil or lubricate the compressor coupler or bottle

fittings. NEVER use any penetrating oil or lubricant such as

WD-40 or 3 in One. If you experience connection difficulties,

please verify that the bottle fitting has been inserted straight

down into the compressor coupler. In the event of continued

difficulties, contact your supplier for assistance.

Keep the oxygen tubing, cord, and unit away from heated or

hot surfaces, including space heaters, blankets, cookers and

similar electrical appliances.

The HomeFill II is equipped with a high pressure relief valve

to ensure user safety. When activated, this safety feature will

emit an extremely loud noise. Should this noise occur, turn the

unit Off and contact your Home Health Care Provider or

Service Representative.

Before moving or repositioning either the compressor or

concentrator, ALWAYS push the power switch to the Off (O)

position and disconnect the AC power cords and the

interconnect hose between the compressor and concentrator.

Failure to follow this procedure may result in damage to the

unit or personal injury.

Children should ALWAYS be supervised around the

HomeFill II unit. When used with the HomeFill table or

similar elevated support surfaces, a child could knock over

the table or other surface thus causing the unit to fall. Failure

to observe this warning may result in personal injury or

product damage.

Handling

Use extreme care when handling and filling an oxygen

cylinder. Full oxygen cylinders are pressurised and can turn

into projectiles if dropped or mishandled.

HomeFill

®

II Compressor 14 Part No 1145805

 WARNING (CONTINUED)

NEVER transport a compressor with a cylinder connected to

or stored on the compressor, otherwise injury or damage can

occur.

DO NOT store filled oxygen bottles near a furnace, hot water

tank, in the trunk of a car or in other areas of high

temperature. Storage in such areas may cause the bottle to

explode or can result in fire.

Part No 1145805 15 HomeFill

®

II Compressor

SECTION 2—INITIAL SETUP

NOTE: Suppliers Only - Refer to Dealer Information on page 9

prior to performing this procedure.

Initial Set Up of Compressor

Compressor Initial Setup Checklist

Before operating the HomeFill II Compressor for the first

time, complete the following checklist:

❑ Choose a location for the compressor.

❑ Transport the compressor to the desired location.

❑ Connect the power cord to the compressor.

❑ Connect the compressor to the concentrator.

Choosing a location

 WARNING

NEVER use near any type of flame or flammable/explosive

substance, vapour or atmosphere.

Keep the oxygen tubing, cord, and unit away from heated

or hot surfaces, including space heaters, blankets, cookers

and similar electrical appliances.

The compressor should be at least three inches away from

walls, curtains or furniture to ensure sufficient air flow.

DO NOT use inside a cupboard.

The compressor should rest on a hard flat stable surface, such

as a table or the Ready Rack.

HomeFill

®

II Compressor 16 Part No 1145805

Compressor Transportation

NOTE: For this procedure, refer to FIGURE 2.1.

 WARNING

NEVER transport a compressor with a cylinder connected

to or stored on the compressor as this may result in injury

or damage.

CAUTION

When transporting the compressor, take care no to bump

the compressor or the connectors into obstacles.

Otherwise, damage to the compressor may occur.

NOTE: For this procedure, refer to FIGURE 2.1.

1. There are two

methods for the safe

transportation of the

compressor:

A. One hand - Hold the

hand grip at the

bottom rear of the

compressor.

B. Both hands - Hold the

hand grips on the

sides of compressor.

FIGURE 2.1 Compressor

Transportation

Installing the Power Cord

NOTE: For this procedure, refer to FIGURE 2.2 on page 17.

1. Ensure the compressor is on a hard flat stable surface, such

as a table or Ready Rack.

2. Make sure the power switch is in the Off (O) position.

3. Plug the power cord into the electric connector in the back

of the compressor.

Hand Grip

Part No 1145805 17 HomeFill

®

II Compressor

4. Plug the opposite end of the power cord into the wall

socket.

FIGURE 2.2 Installing the Power Cord

Connecting the Compressor to the Concentrator

NOTE: For this procedure, refer to FIGURE 2.3 on page 18.

1. Insert one end of the interconnect hose into the outlet

fitting on the back of the concentrator (Detail “A”).

2. Insert the opposite end of the interconnect hose into the

inlet fitting on the side of the compressor (Detail “B”).

NOTE: The metal tabs on the concentrator outlet fitting and the

compressor inlet fitting will pop out with an audible “click” when

the end of the interconnect hose is properly installed (Detail “C”).

3. Loop any excess interconnect hose and secure to the back

of the concentrator with the fastening straps.

Wall

Socket

Power

Cord

Compressor

(REAR)

Electrical

Connection

HomeFill

®

II Compressor 18 Part No 1145805

FIGURE 2.3 Connecting the Compressor to the Concentrator

Insert End of

Interconnect Hose into

Inlet/Outlet Fitting

Metal

Tab

Interconnect

Hose

Compressor

Inlet Fitting

Power

Cord

Outlet Fitting

CONCENTRATOR

TOP VIEW

DETAIL “A”

DETAIL “C”

DETAIL “B”

Part No 1145805 19 HomeFill

®

II Compressor

SECTION 3—CHECKLIST AND

CYLINDER INSPECTION

Compressor Operation Checklist

Complete the following checklist each time the HomeFill II

Compressor is used to fill a cylinder:

❑ Ensure that the concentrator has been On for at least thirty

minutes. Refer to the concentrator Owner's Manual.

❑ Conduct the prefill inspection on the cylinder.

❑ Connect the cylinder to the compressor.

❑ Push the compressor power switch to the On ( ) position.

❑ Examine the indicator lights on the control panel.

❑ Disconnect and remove the full cylinder.

❑ Push the compressor power switch to the Off (O) position.

❑ Repeat this checklist when filling another cylinder.

Cylinder Prefill Inspection

 WARNING

ONLY use cylinders that have the Invacare HomeFill II

connection and label.

All cylinders MUST be inspected before attempting to fill.

Otherwise, injury or damage may occur.

NOTE: For this procedure, refer to FIGURE 3.1 on page 20.

HomeFill

®

II Compressor 20 Part No 1145805

FIGURE 3.1 Cylinder Prefill Inspection

La pagina sta caricando ...

Invacare IOH200AW Manuale utente

Invacare IOH200AW Manuale utente

in altre lingue

Documenti correlati

Altri documenti