2
A. Gas Burners
B. Support Grid for Cookware
C. Control Knobs for Gas Burners
D. Ignitor for Gas Burners (only on certain models)
F. Safety Device (only on certain models) - Activates if
the flame accidentally goes out (spills, drafts, etc.),
interrupting the delivery of gas to the burner.
Close-up View
Congratualtions on choosing an Ariston appliance, which you will find is dependable and easy to use. We recommend
that you read this manual for best performance and to extend the life of your appliance. Thank you.
D
F
A
B
C
How To Use Your Appliance
The position of the corresponding gas burner is indicated
on each control knob.
Gas Burners
The burners differ in size and power. Choose the most
appropriate one for the diameter of the cookware being
used.
The burner can be regulated with the corresonding control
knob by using one of the following settings:
• Off
High
Low
To turn on one of the burners, place a lighted match or
lighter near the burner, press the knob all the way in and
turn in the counter-clockwise direction to the "High" setting.
On those models fitted with a safety device (F), the
knob must be pressed in for about 6 seconds until the
device that keeps the flame lighted warms up.
On those models fitted with an ignitor (D), to light a
burner, simply press the corresponding knob all the way
in and then turn it in the counter-clockwise direction to the
"High" setting, keeping it pressed in until the burner lights.
Caution: If the burner accidently goes out, turn off the
gas with the control knob and try to light it again after
waiting at least 1 minute.
To turn off a burner, turn the knob in the clockwise
direction until it stops (it should be on the “•” setting).
3
Before cleaning or performing maintenance on your
appliance, disconnect it from the electrical power supply.
To extend the life of the cooktop, it is absolutely
indispensable that it be cleaned carefully and
thoroughly on a frequent basis, keeping in mind the
following:
· Do not use steam equipment to clean the appliance.
• Enameled and glass parts must be washed with
lukewarm water without using abrasive powders or
corrosive substances that could damage them;
• The removable parts of the burners should be washed
frequently with warm water and soap, making sure to
remove caked-on substances;
• On cooktops with automatic ignition, the end of the
electronic ignition device must be cleaned carefully and
frequently, making sure that the gas holes are not
clogged;
• the top must be cleaned with glass cleaning products.
Avoid using abrasive products and abrasive sponges
that could scratch the glass.
• the glass surface should be cleaned regularly with a
soultion of warm water and a non-abrasive detergent.
First, remove all food buildup or grease with a cleaning
scraper, e.g. (not supplied) (Fig. A).
Clean the cooking surface when it is still warm with a
suitable cleaning product, then rub with a damp cloth
and dry. Sugar or foods with a high sugar content that
have melted onto the surface must be removed
immediatley with a scraper while the cooking surface
is still hot. Do not use abrasive sponges or cleaning
products under any circumstances. This holds true for
chemically aggressive cleaners, like oven sprays and
stain removers (Fig. B);
Fig. A Fig. B
Greasing the Taps
The taps may jam in time or they may become difficult to
turn. If so, the tap itself must be replaced.
N.B.: This operation must be performed by a technician
authorised by the manufacturer.
How to Keep Your Cooktop in Shape
Practical Advise on Using the Burners
For best performance, follow these general guidelines:
• Use the appropriate cookware for each burner (see
table) in order to prevent the flame from reaching the
sides of the pot or pan;
• Alwasy use cookware with a flat bottom and keep the
lid on;
• When the contents come to a boil, turn the knob to
"Low".
Burner ø Cookware diameter (cm)
Fast (R) 24 - 26
Semi Fast (S) 16 - 20
Auxiliary (A) 10 - 14
To identify the type of burner, refer to the designs in the
section entitled, "Burner and Nozzle Specifications".
Practical Advice
4
Is there a problem?
The burner does not remain on when set to "Low".
Check to make sure that:
• The gas holes are not clogged.
• There are no draughts near the cooking surface.
• The minimum has been adjusted correctly (see the
section entitled, "Minimum Regulation").
The cookware is not stable.
Check to make sure that:
• The bottom of the cookware is perfectly flat.
• The cookware is centered correctly on the burner.
• The support grids have not been inverted.
If, despite all of these checks, the cooktop does not
function properly and problem persists, call the nearest
Merloni Elettrodomestici Customer Service Centre,
informing them of:
- The type of problem.
- The abbreviation used to identify the model (Mod. ...) as
indicated on the warranty.
Never call upon technicians not authorized by the
manufacturer, and refuse to accept spare parts that are
not original.
It may occur that the cooktop does not function or does
not function properly. Before calling customer service for
assistance, lets see what can be done.
First of all, check to see that there are no interruptions in
the gas and electrical supplies, and, in particular, that the
gas valves for the mains are open.
The burner does not light or the flame is not uniform
around the burner.
Check to make sure that:
• The gas holes on the burner are not clogged;
• All of the movable parts that make up the burner are
mounted correctly;
• There are no draughts around the cooking surface.
The flame does not stay lighted on the model with
the safety device.
Check to make sure that:
• You press the knob all the way in;
• You keep the knob pressed in long enough to activate
the safety device.
• The gas holes are not clogged in the area
corresponding to the safety device.
• This manual is for a class 3 built-in cooktop.
• This appliance is designed for non-professional use in
the home and its features and technical characteristics
must not be modified.
• These instructions are only valid for the countries the
symbols for which appear on the manual and the serial
plate.
• The electrical system of this appliance is safe only when
it is correctly connected to an adequate earthing
system, as required by current safety standards.
Prevent children and the disabled from coming into
contact or having access to the following, as they
are possible sources of danger:
- The controls and the appliance in general;
- The packaging (plastic bags, polystyrene, nails, etc.);
- The appliance, during and immediately after use given
the heat generated by its use;
- The appliance when no longer in installed (in this case,
all potentially dangerous parts must be made safe).
The following should be avoided:
- Touching the appliance with wet parts of the body;
- Using the appliance with bare feet;
- Pulling on the appliance or the power supply cord to
disconnect them from the electrical outlet;
- Improper and/or dangerous use;
- Obstructing the ventilation or heat dissipation slots;
- Allowing the power supply cord of small appliances to
come into contact with the hot parts of the cooktop;
- Exposure to atmospheric agents (rain, sun);
- Using flammable liquids nearby;
- Using adaptors, multiple outlet plugs and/or extensions;
- Using unstable or deformed cookware;
- The top made is resistant to sudden temperature
changes and shocks. However, if it is struck with
pointed utensils or objects such as cutting knives,
it may crack or break. If this occurs, disconnect
the appliance immediately from the power supply
and contact an authorised service centre.
- Trying to install or repair the appliance without the
assistance of qualified personnel.
The assistance of qualified personnel must be called
upon in the following cases:
- Installation (in accordance with the manufacturer's
instructions);
- When in doubt about the operation of the appliance;
- Replacement of the electrical outlet becuase it is
incompatible with the plug.
Contact service centers authorized by the
manufacturer in the following cases:
- When in doubt about the condition of the appliance
after having removed the packing;
- Damage to or replacement of the power supply cord;
- In the case of a breakdown or malfunction: ask for
original spare parts.
Safety Is a Good Habit to Get Into
To maintain the EFFICIENCY and SAFETY of this appliance, we recommend:
• call only the Service Centers authorized by the manufacturer
• always use original Spare Parts
5
It is recommended that you follow the guidelines
below:
- Only use the appliance to cook food, avoiding all other
uses;
- Check the condition of the appliance after it has been
unpacked;
- Disconnect the appliance from the power supply in the
event of malfunction and always before cleaning or
maintenance;
- When not in use, disconnect the appliance from the
power supply and turn off the gas valve (if present);
- Always check to make sure that the control knobs are
on the “•”/”o” setting when the appliance is not in use;
- Cut the power supply cord after disconnecting it from
the electrical mains when you decide to no longer use
the appliance.
• The manufacturer will not be held liable for any
damages arising out of : incorrect installation or
improper, incorrect or unreasonable use..
Installation Instructions for built-in
The following instructions are intended for the installer so
that the installation and maintenance procedures may be
followed in the most professional and expert manner
possible. Important: Disconnect the appliance from the
electrical supply before performing any maintenance
or regulation upkeep work.
Positioning the Cooktop
Important: this unit may be installed and used only in
permanently ventilated rooms in accordance with British
Standard Codes Of Practice: B.S. 6172 / B.S. 5440, Par.
2 and B.S. 6891 Current Editions. The following
requirements must be observed:
a) The room must be fitted with a ventilation system which
vents smoke and gases from combustion to the outside.
This must be done by means of a hood or electric
ventilator that turns on automatically each time the hood
is operated.
In a chimney stack or branched flue. Directly to the Outside
(exclusively for cooking appliances)
b) The room must also allow for the influx of the air needed
for proper combustion. The flow of air for combustion
purposes must not be less than 2 m³/h per kW of installed
capacity. The supply of said air can be effected by means
of direct influx from the outside through a duct with a
inner cross section of at least 100 cm² which must not be
able to be accidentally blocked. Those appliances which
are not fitted with a safety device to prevent the flame
from accidentally going out must have a ventilation
opening twice the size otherwise required, i.e. a minimum
of 200cm² (Fig. A). Otherwise, the room can be vented
indirectly through adjacent rooms fitted with ventilation
ducts to the outside as described above, as long as the
adjacent rooms are not shared areas, bedrooms or
present the risk of fire (Fig. B).
Detail A Adjacent Room to be
Room Vented
A
Examples of ventilation holes Enlarging the ventilation slot
for comburant air. between window and floor.
Fig. A Fig. B
c) Intensive and prolonged use of the appliance may ne-
cessitate supplemental ventilation, e.g. opening a window
or increasing the power of the air intake system (if
present).
d) Liquidified petroleum gases are heavier than air and, as
a result, settle downwards. Rooms in which LPG tanks
are installed must be fitted with ventilation openings to
the outside in order to allow the gas to escape in the
event of a leak. Therefore, LPG tanks, whether empty or
partially full, must not be installed or stored in rooms or
spaces below ground level (cellars, ect.). It is also a good
idea to keep only the tank currently being used in the
room, making sure that it is not near sources of heat
(ovens, fireplaces, stoves, etc.) that could raise the internal
temperature of the tank above 50°C.
Installation of Built-in Cooktops
The appliance can be installed next to furniture units which
are no taller than the top of the cooker hob. The wall in
direct contact with the back panel of the cooker must be
made of non-flammable material. During operation the
back panel of the cooker could reach a temperature of
50°C above room temperature. For proper installation of
the cooker, the following precautions must be taken:
a) If the cabinet(s) located next to the cooktop are higher
than the cooktop itself, the cabinet(s) must be installed
at least 600 mm from the edge cooktop;
b) Hoods must be installed in accordance with the
instructions contained in the installation manual for the
hoods themselves, and no less than 650 mm from the
6
cooktop;
c) The cabinets installed next to the hood must be located
at a height of at least 420 mm from the top, (as shown
in Fig. C).
HOOD
420
Min.
min.
650
mm. with hood
min.
700
mm. without hood
mm.
600
Min. mm.
420
Min. mm.
Fig. C
d) Should the cooktop be installed directly under a
cupboard, the latter should be at least 700 mm
(millimetres) from the top, as shown in Fig. C.
e) The dimensions of the cutout for the appliance must
be those indicated in the figure.
555 mm.
55 mm.
475 mm.
Before fastening the cooktop in place, position the seal
(supplied) along the perimeter of the countertop, as
shown in the figure.
Clamps are provided to fasten the cooktop to counters
measuring from 20 to 40 mm in thickness. To fasten
the cooktop securely, it is recommended that all the
clamps be used.
Fastening Clamps - Assembly Diagram
Clamp Position for Clamp Position for
H=30mm top H=40mm top
Front
Clamp Position for
H=20mm top Back
N.B: Use the clamps contained in the "accessory kit."
f) In the event the cooktop is not installed above a built-
in oven, a wood panel must be inserted as insulation.
This panel must be placed at least 20 mm from the
bottom of the cooktop itself.
Important: When installing the cooktop above a built-in
oven, the oven should be placed on two wooden strips; in
the case of a joining cabinet surface, remember to leave
a space of at least 45 x 560 mm at the back.
560 mm.
45 mm.
When installing the cooktop above a built-in oven without
forced ventilation, ensure that there are air inlets and
outlets for ventilating the interior of the cabinet adequately.
Gas Connection for Cooktop
The cooktop should be connected to the gas supply by an
authorized installer. During installation of this product it is
essential to fit an approved gas tap to isolate the supply
from the appliance for the convenience of any subsequent
removal or servicing. Connection of the appliance to the
gas mains or liquid gas tanks must be carried out
according to the safety standards currently in force, and
only after it is ascertained that it is suitable for the type of
gas to be used. If not, follow the instructions indicated in
the section entitled, “Adapting the Cooktop for Different
Types of Gas”. If the cooktop is to be connected to tanks
containing liquid gas, use pressure regulators that comply
with current safety standards.
Important: To insure that the appliance operates safety,
7
the gas is regulated correctly and your appliance lasts
over time, make sure that gas pressure levels comply with
the indications given in Table 1, “Nozzle and Burner
Specifications”.
Gas Connection to Non-flexible Pipe
(copper or steel)
Connection to the gas source must be done in such a way
as to not create any stress points at any part of the
appliance.
The appliance is fitted with an adjustable, "L" shaped
connector and a gasket for the attachment to the gas supply.
Should this connector have to be turned, the gasket must be
replaced (supplied with the appliance).
The gas feed connector to the appliance is a threaded,
male 1/2" connector for round gas pipe.
Gas Connection to Flexible Steel Pipe
The gas feed connector to the appliance is a threaded,
male 1/2" connector for round gas pipe. Only use pipes,
tubes and gaskets that comply with current safety codes.
The maximum length of the flexible pipes must not exceed
2000 mm. Once the connection has been made, ensure
that the flexible metal tube does not touch any moving
parts and is not crushed.
Check the Seal
Once the appliance has been installed, make sure all the
connections are properly sealed, using a soapy water
solution. Never use a flame.
Electrical Connection
The cooktops fitted with a tripolar electrical supply cord
are designed to be be used with alternating current
according to the indications on the rating plate located
under the cooktop. The earthing wire can be identified by
its yellow-green colour.
In the case of installation over a built-in electric oven,
the electrical connections for the cooktop and oven
should be independent, not only for safety purposes, but
also to facilitate removal of one or both in the future.
Electrical Connection for Gas Cooktop
Fit the supply cord with a standard plug for the demand
rate indicated on the rating plate or connect it directly to
the electrical mains. In the latter case, a single pole switch
must be placed between the appliance and the mains,
with a minimum opening between the contacts of 3 mm in
compliance with current safety codes (the earthing wire
must not be interrupted by the switch). The power supply
cord must be positioned so that it does not reach a tem-
perature in excess of 50°C above room temperature at
any point.
Before making the actual connection, make sure that:
• The fuse and electrical system can withstand the load
required by the appliance;
• That the electrical supply system is equiped with an
efficient earth hook-up according to the norms and
regulations prescribed by law;
• That the plug or switch is easily accessible.
Important: the wires in the mains lead are coloured in
accordance with the following code:
Green & Yellow - Earth
Blue - Neutral
Brown - Live
As the colours of the wires in the mains lead may not
correspond with the coloured markings identifying the
terminals in your plug, proceed as follows:
Connect the Green & Yellow wire to the terminal marked
“E” or or coloured Green or Green & Yellow.
Connect the Brown wire to the terminal marked “L” or
coloured Red.
Connect the Blue wire to the terminal marked “N” or
coloured Black.
Adapting the Cooktop for Different Types of Gas
To adapt the cooktop to a different type of gas than that
for which it was designed, (see the sticker under the hob
or on the packaging), the burner nozzles must be changed,
as follows:
• Remove the pan supports and slide the burners out of
the cooktop.
• Unscrew the nozzles using a 7mm socket wrench and
replace them with those for the new type of gas. (See
table 1, “Burner and Nozzle Specifications”).
• Reassemble the parts following the instructions in
reverse order.
• On completing the operation, replace the old rating label
with the one showing the new type of gas; the sticker
is available from our Service Centres.
If the gas pressure is different than that prescribed, a
pressure regulator must be installed at the source, in
compliance with national standards governing the use of
piped gas regulators.
Regulation of Air Supply to the Burner
The burners do not need a primary air regulator.
Minimum Regulation
Minimum regulation.
• Turn the gas valve to minimum.
• Remove the knob and turn the regulator screw
(positioned either on the side of the top or inside the
shaft) clockwise until the flame becomes small but
regular.
N.B.: In the case of liquid gas, the regulation screw must
be fully screwed in (clockwise).
• Make sure that, when the knob is turned rapidly high
to low, the flame does not go out.
• In the event of a malfunction on appliances with the
security device (thermocouple) when the gas supply
is set at minimum, increase the minimum supply levels
using the regulator screw.
Once the adjustment has been made, apply sealing wax,
or a suitable substitute, to the old seals on the by-pass.
8
Burners and Nozzle Specifications
Table 1 Liquid Gas Natural Gas
Burner Diameter
(mm)
Thermal Power
kW (p.c.s.*)
By-pass
1/100
(mm)
Nozzle
1/100
Flow*
g/h
Nozzle
1/100
Flow*
l/h
Nozzle
1/100
Flow*
l/h
Nom. Red. (1) (mm) *** ** (mm) (mm)
Fast
(Large) (R)
100 3.00 0.7 41 39 86 218 214 116 286 143 286
Semi Fast
(Medium) (S)
75 1.65 0.4 30 28 64 120 118 96 157 105 157
Auxiliary
(Small) (A)
55 1.00 0.4 30 28 50 73 71 71 95 80 95
Supply
pressures
Nominal (mbar)
Minimum (mbar)
Maximum (mbar)
28-30
20
35
37
25
45
20
17
25
13
6,5
18
* At 15°C and 1013 mbar-dry gas
** Propane P.C.S. = 50.37 MJ/kg.
*** Butane P.C.S. = 49.47 MJ/kg.
Natural P.C.S. = 37.78 MJ/m
3
(1) Only for appliances with the security device (Ref. F).
7
This appliance complies with the following European Economic Community directives:
- 73/23/EEC of 19/02/73 (Low Voltage) and subsequent modifications;
- 89/336/EEC of 03/05/89 (Electromagnetic Compatibility) and subsequent modifications;
- 90/396/EEC of 29/06/90 (Gas) and subsequent modifications;
- 93/68/EEC of 22/07/93 and subsequent modifications.
- 2002/96/EC
The European Directive 2002/96/EC on Waste Electrical and Electronic Equipment (WEEE), requires that old household
electrical appliances must not be disposed of in the normal unsorted municipal waste stream. Old appliances must be
collected separately in order to optimise the recovery and recycling of the materials they contain and reduce the impact
on human health and the environment. The crossed out “wheeled bin” symbol on the product reminds you of your
obligation, that when you dispose of the appliance it must be separately collected.
Consumers should contact their local authority or retailer for information concerning the correct disposal of their old
appliance.
CISTD 640...
Áëàãîäàðèì âàñ çà âûáîð èçäåëèÿ Ariston, íàäåæíîãî è ïðîñòîãî â îáðàùåíèè. Äëÿ çíàêîìñòâà ñ èçäåëèåì, ñ
ïîðÿäêîì åãî îïòèìàëüíîé è äîëãîñðî÷íîé ýêñïëóàòàöèè ðåêîìåíäóåì ïðî÷èòàòü äàííîå ðóêîâîäñòâî ïî
ýêñïëóàòàöèè. Áëàãîäàðèì çà âíèìàíèå
D
F
A. Ãàçîâûå êîíôîðêè
B. Îïîðíûå ðåøåòêè äëÿ êàñòðþëü
C. Ðóêîÿòêè ðåãóëÿöèè ãàçîâûõ êîíôîðîê
D. Êíîïêà çàæèãàíèÿ ãàçîâûõ êîíôîðîê (èìååòñÿ
òîëüêî â íåêîòîðûõ ìîäåëÿõ)
F. Çàùèòíîå óñòðîéñòâî (èìååòñÿ òîëüêî â
íåêîòîðûõ ìîäåëÿõ) - Ñðàáàòûâàåò ïðè ñëó÷àéíîì
ãàøåíèè ïëàìåíè (âûêèïàíèå æèäêîñòåé èç
êàñòðþëü, ñêâîçíÿêè è ò.ä.), ïåðåêðûâàÿ ïîäà÷ó ãàçà
íà êîíôîðêó.
Äåòàëüíûé âèä èçäåëèÿ
A
B
C
Íà êàæäîé ðóêîÿòêå ïîêàçàíî ïîëîæåíèå
ñîîòâåòñòâóþùåé êîíôîðêè íà âàðî÷íîé ïàíåëè.
Ãàçîâûå êîíôîðêè
Êîíôîðêè èìåþò ðàçíóþ ìîùíîñòü è ðàçìåð.
Âûáåðèòå êîíôîðêó, íàèáîëåå ñîîòâåòñòâóþùóþ
äèàìåòðó èñïîëüçóåìîé ïîñóäû.
Ïðè ïîìîùè ñîîòâåòñòâóþùèé ðóêîÿòêè ìîæíî
óñòàíîâèòü îäèí èç ñëåäóþùèõ ðåæèìîâ êîíôîðêè:
Âûêëþ÷åíî
Ìàêñèìàëüíûé
Ìèíèìàëüíûé
Äëÿ çàæèãàíèÿ îäíîé èç êîíôîðîê ïîäíåñèòå ê íåé
çàææåííóþ ñïè÷êó èëè çàæèãàëêó, íàæìèòå äî óïîðà è
ïîâåðíèòå ïðîòèâ ÷àñîâîé ñòðåëêè ñîîòâåòñòâóþùóþ
ðóêîÿòêó â ïîëîæåíèå ìàêñèìàëüíîãî ïëàìåíè.
 ìîäåëÿõ, îñíàùåííûõ óñòðîéñòâîì
áåçîïàñíîñòè F, íåîáõîäèìî äåðæàòü ðóêîÿòêó
êîíôîðêè íàæàòîé ïðèìåðíî 6 ñåêóíä äî òåõ ïîð, ïîêà
íå íàãðååòñÿ óñòðîéñòâî, àâòîìàòè÷åñêè
ïîääåðæèâàþùåå ãîðåíèå ïëàìåíè.
Ïîðÿäîê ýêñïëóàòàöèè ãàçîâîé ïëèòû
 ìîäåëÿõ, îñíàùåííûõ ñâå÷îé çàæèãàíèÿ D, äëÿ
âêëþ÷åíèÿ íóæíîé êîíôîðêè äîñòàòî÷íî íàæàòü äî
óïîðà ñîîòâåòñòâóþùóþ ðóêîÿòêó, çàòåì ïîâåðíóòü åå
ïðîòèâ ÷àñîâîé ñòðåëêè â ïîëîæåíèå ìàêñèìàëüíîãî
ïëàìåíè, óäåðæèâàÿ åå íàæàòîé âïëîòü äî çàæèãàíèÿ
ïëàìåíè.
Ïðåäóïðåæäåíèå: ïðè ñëó÷àéíîì ãàøåíèè ïëàìåíè
êîíôîðêè ïîâåðíèòå ðóêîÿòêó óïðàâëåíèÿ â ïîëîæåíèå
âûêëþ÷åíî è ïîïûòàéòåñü âíîâü çàæå÷ü êîíôîðêó
òîëüêî ïî ïðîøåñòâèè íå ìåíåå 1 ìèíóòû.
Äëÿ âûêëþ÷åíèÿ êîíôîðêè ïîâåðíèòå ðóêîÿòêó ïî
÷àñîâîé ñòðåëêå âïëîòü äî ãàøåíèÿ ïëàìåíè
(ïîëîæåíèå, îáîçíà÷åííîå ñèìâîëîì «»).
10
Ïåðåä íà÷àëîì êàêîé-ëèáî îïåðàöèè ïî îáñëóæèâàíèþ
èëè ÷èñòêå îòñîåäèíèòü èçäåëèå îò ñåòè
ýëåêòðîïèòàíèÿ.
Äëÿ äëèòåëüíîé ñëóæáû âàðî÷íîé ïàíåëè âàæíî
ðåãóëÿðíî ïðîèçâîäèòü åå òùàòåëüíóþ îáùóþ
÷èñòêó, ó÷èòûâàÿ ñëåäóþùåå:
· íå èñïîëüçóéòå äëÿ ÷èñòêè ïàðîâûå àãðåãàòû
Ìîéòå ýìàëèðîâàííûå è ñòåêëÿííûå ÷àñòè òåïëîé
âîäîé áåç èñïîëüçîâàíèÿ àáðàçèâíûõ ïîðîøêîâ è
êîððîçèéíûõ ìîþùèõ ñðåäñòâ, êîòîðûå ìîãóò
ïîâðåäèòü òàêèå ïîâåðõíîñòè.
íåîáõîäèìî ðåãóëÿðíî ìûòü ñúåìíûå ÷àñòè
êîíôîðîê ãîðÿ÷åé âîäîé ñ ìîþùèì ñðåäñòâîì,
òùàòåëüíî óäàëÿÿ âñå âîçìîæíûå íàëåòû;
íà âàðî÷íûõ ïàíåëÿõ, îñíàùåííûõ àâòîìàòè÷åñêèì
çàæèãàíèåì, ñëåäóåò ðåãóëÿðíî ÷èñòèòü
íàêîíå÷íèêè óñòðîéñòâ ìãíîâåííîãî ýëåêòðîííîãî
çàæèãàíèÿ è ïðîâåðÿòü, ÷òîáû îòâåðñòèÿ ãàçîâûõ
êîíôîðîê íå áûëè çàñîðåíû;
äëÿ óõîäà çà ïîâåðõíîñòüþ âàðî÷íîé ïàíåëè
èñïîëüçóéòå ÷èñòÿùèå ñðåäñòâà äëÿ ñòåêëà. Íå
ñëåäóåò èñïîëüçîâàòü àáðàçèâíûå ÷èñòÿùèå
ñðåäñòâà è ãóáêè, êîòîðûå ìîãóò ïîöàðàïàòü
ñòåêëÿííóþ ïîâåðõíîñòü.
Íåîáõîäèìî ðåãóëÿðíî ÷èñòèòü ïîâåðõíîñòü
âàðî÷íîé ïàíåëè ðàñòâîðîì òåïëîé âîäû ñ
íåàáðàçèâíûì ìîþùèì ñðåäñòâîì. Ñíà÷àëà
óäàëèòå ñ âàðî÷íîé ïàíåëè âñå îñòàòêè ïèùè è
æèðíûõ áûðçã ïðè ïîìîùè ñêðåáêà, íàïðèìåð
(íå ïðèëàãàåòñÿ) (Ðèñ. À).
Ïðîèçâîäèòå ÷èñòêó âàðî÷íîé ïàíåëè, ïîêà îíà
òåïëàÿ, ïðè ïîìîùè ñïåöèàëüíîãî ÷èñòÿùåãî
ñðåäñòâà, ïðîòðèòå âëàæíîé òðÿïêîé è âûñóøèòå.
Âàæíî íåçàìåäëèòåëüíî óäàëÿòü ñ åùå ãîðÿ÷åé
âàðî÷íîé ïàíåëè ñàõàð èëè ïðîäóêòû ñ âûñîêèì
ñîäåðæàíèåì ñàõàðà ïðè ïîìîùè ñïåöèàëüíîãî
ñêðåáêà. Êàòåãîðè÷åñêè çàïðåùàåòñÿ èñïîëüçîâàòü
àáðàçèâíûå ãóáêè èëè ÷èñòÿùèå ñðåäñòâà, à òàêæå
ñëåäóåò èçáåãàòü èñïîëüçîâàíèÿ õèìè÷åñêè
àãðåññèâíûõ ñðåäñòâ òàêèõ êàê ñïðàé äëÿ ÷èñòêè
äóõîâîê èëè ïÿòíîâûâîäèòåëåé (Ðèñ. Â);
Óõîä çà âàðî÷íîé ïàíåëüþ
Ïðàêòè÷åñêèå ñîâåòû ïî ýêñïëóàòàöèè ãàçîâûõ
êîíôîðîê
Äëÿ ìàêñèìàëüíîé îòäà÷è èçäåëèÿ ñëåäóåò ïîìíèòü:
äëÿ êàæäîé êîíôîðêè èñïîëüçóéòå ïîäõîäÿùóþ
ïîñóäó (ñìîòðè òàáëèöó) ñ òåì, ÷òîáû ïëàìÿ
êîíôîðêè íå âûõîäèëî èç-ïîä äíà ïîñóäû.
âñåãäà èñïîëüçóéòå ïîñóäó ñ ïëîñêèì äíîì è ñ
êðûøêîé.
â ìîìåíò çàêèïàíèÿ ïîâåðíèòå ðóêîÿòêó â
ïîëîæåíèå ìàëîãî ïëàìåíè.
Ðåêîìåíäàöèè ïî ýêñïëóàòàöèè
Ðèñ. À Ðèñ. Â
Ñìàçêà ðóêîÿòîê êîíôîðîê
Ñî âðåìåíåì ðóêîÿòêè âàðî÷íîé ïàíåëè ìîãóò
çàáëîêèðîâàòüñÿ èëè âðàùàòüñÿ ñ òðóäîì, ïîýòîìó
ïîòðåáóåòñÿ ïðîèçâåñòè èõ âíóòðåííþþ ÷èñòêó è
çàìåíó âñåé ðóêîÿòêè.
ÏÐÈÌÅ×ÀÍÈÅ: Äàííàÿ îïåðàöèÿ äîëæíà
âûïîëíÿòüñÿ òåõíèêîì, óïîëíîìî÷åííûì
ïðîèçâîäèòåëåì.
Äëÿ îïðåäåëåíèÿ òèïà êîíôîðêè ñìîòðèòå ðèñóíêè â
ïàðàãðàôå «Õàðàêòåðèñòèêè êîíôîðîê è ôîðñóíîê».
Ãîðåëêà Äèàìåòð äíà ïîñóäû
(cì)
Áûñòðàÿ (R) 24 - 26
Ïîëóáûñòðàÿ (S) 16 - 20
Äîïîëíèòåëüíàÿ (A) 10 - 14
×òî äåëàòü, åñëè âàðî÷íàÿ ïàíåëü ðàáîòàåò íåèñïðàâíî
èëè íå ðàáîòàåò âîâñå. Ïåðåä òåì êàê îáðàòèòüñÿ â öåíòð
òåõíè÷åñêîãî îáñëóæèâàíèÿ, ñëåäóåò ñàìîñòîÿòåëüíî
ïðîèçâåñòè ñëåäóþùèå ïðîâåðêè.
Ïðåæäå âñåãî ñëåäóåò ïðîâåðèòü, ÷òîáû íè â ñåòè
ýëåêòðîïèòàíèÿ, íè íà ãàçîïðîâîäå íå áûëî ðàçðûâîâ, è â
÷àñòíîñòè, ÷òîáû îáùèé ãàçîâûé êðàí áûë îòêðûò.
Êîíôîðêà íå çàæèãàåòñÿ, èëè ïëàìÿ ãîðèò
íåðàâíîìåðíî.
Ïðîâåðüòå ñëåäóþùåå:
Ôîðñóíêè ãàçîâîé êîíôîðêè íå äîëæíû áûòü çàñîðåíû.
Âñå ñúåìíûå ÷àñòè êîíôîðêè äîæíû áûòü óñòàíîâëåíû
ïðàâèëüíî.
Ðÿäîì ñ ãàçîâîé âàðî÷íîé ïàíåëüþ íå äîëæíî áûòü
ñêâîçíÿêîâ.
 ìîäåëÿõ âàðî÷íîé ïàíåëè, îñíàùåííûõ çàùèòíûì
óñòðîéñòâîì, êîíôîðêà çàãîðàåòñÿ è ñðàçó ãàñíåò.
Ïðîâåðüòå ñëåäóþùåå:
Ðóêîÿòêà êîíôîðêè íàæàòà íå äî óïîðà.
Ðóêîÿòêà áûëà íàæàòà â òå÷åíèå âðåìåíè,
íåäîñòàòî÷íîãî äëÿ âêëþ÷åíèÿ çàùèòíîãî óñòðîéñòâà.
Çàñîðåíû ôîðñóíêè ãàçîâîé êîíôîðêè, ðàñïîëîæåííûå
íàïðîòèâ çàùèòíîãî óñòðîéñòâà.
Êîíôîðêà ãàñíåò â ïîëîæåíèè ìàëîãî ïëàìåíè.
Ïðîâåðüòå ñëåäóþùåå:
Çàñîðåíû ôîðñóíêè ãàçîâîé êîíôîðêè.
Ðÿäîì ñ ãàçîâîé âàðî÷íîé ïàíåëüþ íå äîëæíî áûòü
ñêâîçíÿêîâ.
Íåïðàâèëüíàÿ ðåãóëÿöèÿ ìàëîãî ïëàìåíè (Ñìîòðèòå
ïàðàãðàô «Ðåãóëÿöèÿ ìàëîãî ïëàìåíè»).
Íåñòàáèëüíûå êàñòðþëè
Ïðîâåðüòå ñëåäóþùåå:
Äíî êàñòðþëè äîëæíî áûòü èäåàëüíî ïëîñêèì.
Êàñòðþëÿ äîëæíà ñòîÿòü ðîâíî ïî öåíòðó êîíôîðêè.
Îïîðíûå ðåøåòêè íà âàðî÷íîé ïàíåëè óñòàíîâëåíû
íåïðàâèëüíî.
Åñëè íåñìîòðÿ íà âñå ïðîâåðêè âàðî÷íàÿ ïàíåëü íå
ðàáîòàåò, è îáíàðóæåííàÿ íåèñïðàâíîñòü íå óñòðàíÿåòñÿ,
îáðàòèòåñü â áëèæàéøèé Öåíòð òåõíè÷åñêîãî îáñëóæèâàíèÿ
Merloni Elettrodomestici, èìåÿ ïîä ðóêîé ñëåäóþùèå äàííûå:
- îïèñàíèå íåèñïðàâíîñòè.
- Êîä ìîäåëè (Ìîä. ...) óêàçàííûé â ãàðàíòèéíîì
ñåðòèôèêàòå.
Íèêîãäà íå îáðàùàéòåñü ê íåóïîëíîìî÷åííûì òåõíèêàì è
íå äîïóñêàéòå óñòàíîâêè íåîðèãèíàëüíûõ çàïàñíûõ ÷àñòåé.
×òî äåëàòü â ñëó÷àå âîçíèêíîâåíèÿ íåèñïðàâíîñòåé
Äàííîå òåõíè÷åñêîå ðóêîâîäñòâî îòíîñèòñÿ ê
âñòðàèâàåìîé âàðî÷íîé ïàíåëè êëàññà 3.
Äàííîå èçäåëèå ïðåäíàçíà÷àåòñÿ äëÿ
íåïðîôåññèîíàëüíîãî èñïîëüçîâàíèÿ â äîìàøíèõ
óñëîâèÿ, è åãî õàðàêòåðèñòèêè íå äîëæíû èçìåíÿòüñÿ.
Äàííûå èíñòðóêöèè äåéñòâèòåëüíû òîëüêî â òåõ ñòðàíàõ,
îáîçíà÷åíèÿ êîòîðûõ ïðèâîäÿòñÿ â òåõíè÷åñêîì
ðóêîâîäñòâå è íà çàâîäñêîé òàáëè÷êå.
Ýëåêòðè÷åñêàÿ áåçîïàñíîñòü äàííîãî èçäåëèÿ
ãàðàíòèðóåòñÿ, òîëüêî åñëè îíî áóäåò ïðàâèëüíî
ïîäñîåäèíåíî ê íàäëåæàùåé ñèñòåìå çàçåìëåíèÿ â
ñîîòâåòñòâèè ñ äåéñòâóþùèìè íîðìàòèâàìè ïî
áåçîïàñíîñòè.
Òàê êàê ãàçîâàÿ âàðî÷íàÿ ïàíåëü ÿâëÿåòñÿ
èñòî÷íèêîì îïàñíîñòè, íå äîïóñêàòü äåòåé è
èíâàëèäîâ ê:
- ãàçîâîé âàðî÷íîé ïàíåëè è ê åå ðåãóëÿöèÿì;
- óïàêîâî÷íûì ìàòåðèàëàì (ïàêåòàì, ïîëèñòèðîëó,
ãâîçäÿì è ò.ä.);
- ãàçîâîé âàðî÷íîé ïàíåëè â ïðîöåññå èëè ñðàçó æå ïîñëå
åå ýêñïëóàòàöèè âî èçáåæàíèå îæåãîâ;
- âûêëþ÷åííîé âàðî÷íîé ïàíåëè (â äàííîì ñëó÷àå
íåîáõîäèìî îáåçîïàñèòü âñå ïîòåíöèàëüíî îïàñíûå
êîìïîíåíòû).
Èçáåãàéòå ñëåäóþùèõ äåéñòâèé:
- íå ïðèêàñàéòåñü ê âàðî÷íîé ïàíåëè ìîêðûìè ÷àñòÿìè
òåëà:
- íå ïîëüçóéòåñü âàðî÷íîé ïàíåëüþ áîñèêîì;
- íå òÿíèòå çà ïðîâîä ýëåêòðîïèòàíèÿ èëè çà ñàìó
âàðî÷íóþ ïàíåëü äëÿ åå îòñîåäèíåíèÿ îò ñåòè
ýëåêòðîïèòàíèÿ;
- èçáåãàéòå íåóìåñòíûõ è îïàñíûõ äåéñòâèé;
- íå çàêðûâàéòå âåíòèëÿöèîííûå îòâåðñòèÿ èëè
îòâåðñòèÿ äëÿ ðàññåèâàíèÿ òåïëà;
- ýë. ïðîâîäà ðàçëè÷íûõ äîìàøíèõ ýëåêòðîïðèáîðîâ íå
äîëæíû êàñàòüñÿ ãîðÿ÷èõ ÷àñòåé âàðî÷íîé ïàíåëè;
- íà âàðî÷íóþ ïàíåëü íå äîëæíû âîçäåéñòâîâàòü
àòìîñôåðíûå ÿâëåíèÿ (äîæäü, ñîëíöå);
- íå èñïîëüçóéòå ãîðþ÷èå æèäêîñòè ðÿäîì ñ âàðî÷íîé
ïàíåëüþ;
- íå èñïîëüçóéòå ïåðåõîäíèêè, òðîéíèêè è/èëè
óäëèíèòåëè;
- íå èñïîëüçóéòå íåñòàáèëüíûå èëè äåôîðìèðîâàííûå
êàñòðþëè;
- Êóõîííàÿ ïëèòà èç ñòåêëîêåðàìèêè ÿâëÿåòñÿ
óñòîé÷èâîé ê òåìïåðàòóðíûì ñêà÷êàì è ê óäàðàì. Òåì
íå ìåíåå îíà ìîæåò ðàçáèòüñÿ ïðè óäàðå îñòðûì
ïðåäìåòîì.  ýòîì ñëó÷àå íåîáõîäèìî
íåçàìåäëèòåëüíî îòêëþ÷èòü ýëåêòðîïèòàíèå è
îáðàòèòüñÿ çà ðåìîíòîì â óïîëíîìî÷åííûé öåíòð
òåõíè÷åñêîãî îáñëóæèâàíèÿ.
- íå ïûòàéòåñü ïðîèçâåñòè óñòàíîâêó èëè ðåìîíò ïëèòû
ñàìîñòîÿòåëüíî, áåç ñîäåéñòâèÿ êâàëèôèöèðîâàííîãî
ïåðñîíàëà.
 ñëåäóþùèõ ñëó÷àÿõ íåîáõîäèìî îáðàòèòüñÿ ê
êâàëèôèöèðîâàííîìó ïåðñîíàëó â îáÿçàòåëüíîì
ïîðÿäêå:
- óñòàíîâêà (â ñîîòâåòñòâèè ñ èíñòðóêöèÿìè
ïðîèçâîäèòåëÿ);
- â ñëó÷àå ñîìíåíèé êàñàòåëüíî èñïðàâíîãî
ôóíêöèîíèðîâàíèÿ âàðî÷íîé ïàíåëè;
- äëÿ çàìåíû ýë. ðîçåòêè â ñëó÷àå åå íåñîâìåñòèìîñòè ñ
ýë. âèëêîé âàðî÷íîé ïàíåëè.
 ñëåäóþùèõ ñëó÷àÿõ íåîáõîäèìî îáðàòèòüñÿ â
óïîëíîìî÷åííûå öåíòðû òåõíè÷åñêîãî îáñëóæèâàíèÿ:
- â ñëó÷àå ñîìíåíèÿ êàñàòåëüíî öåëîñòíîñòè âàðî÷íîé
ïàíåëè ïîñëå åå ðàñïàêîâêè;
- â ñëó÷àå ïîâðåæäåíèÿ èëè çàìåíû ïðîâîäà
Õîðîøåå ïðàâèëî - áåçîïàñíîñòü
Äëÿ îáåñïå÷åíèÿ ýôôåêòèâíîé è áåçîïàñíîé ýêñïëóàòàöèè äàííîãî áûòîâîãî ýëåêòðîïðèáîðà:
îáðàùàéòåñü òîëüêî â óïîëíîìî÷åííûå öåíòðû òåõíè÷åñêîãî îáñëóæèâàíèÿ
âñåãäå òðåáóéòå óñòàíîâêó îðèãèíàëüíûõ çàïàñíûõ ÷àñòåé
12
ýëåêòðîïèòàíèÿ;
- â ñëó÷àå íåèñïðàâíîñòè èëè ïëîõîãî ôóíêöèîíèðîâàíèÿ
èçäåëèÿ, çàïðàøèâàÿ óñòàíîâêó îðèãèíàëüíûõ çàïàñíûõ
÷àñòåé.
Ðåêîìåíäóåìûå îïåðàöèè:
- èñïîëüçóéòå âàðî÷íóþ ïàíåëü èñêëþ÷èòåëüíî äëÿ
ïðèãîòîâëåíèÿ ïèùè, èçáåãàÿ åå èñïîëüçîâàíèÿ â èíûõ
öåëÿõ;
- ïðîâåðüòå öåëîñòíîñòü âàðî÷íîé ïàíåëè, ñíÿâ ñ íåå
óïàêîâêó;
- â ñëó÷àå íåèñïðàâíîãî ôóíêöèîíèðîâàíèÿ âàðî÷íîé
ïàíåëè è ïåðåä îñóùåñòâëåíèåì êàêîé-ëèáî îïåðàöèè ïî
åå òåõíè÷åñêîìó îáñëóæèâàíèþ èëè ÷èñòêè íåîáõîäèìî
îòñîåäèíèòü ïàíåëü îò ñåòè ýëåêòðîïèòàíèÿ;
- â ñëó÷àå ïðîñòîÿ íåîáõîäèìî îòñîåäèíèòü âàðî÷íóþ
ïàíåëü îò ñåòè ýëåêòðîïèòàíèÿ è ïåðåêðûòü êðàí ïîäà÷è
ãàçà (åñëè îí ïðåäóñìîòðåí);
- âñåãäà ïðîâåðÿéòå, ÷òîáû ðóêîÿòêè íàõîäèëèñü â
ïîëîæåíèè /o, êîãäà èçäåëèå íå èñïîëüçóåòñÿ;
- ïî îêîí÷àíèè ñðîêà ñëóæáû âàðî÷íîé ïàíåëü
íåîáõîäèìî îòðåçàòü ïðîâîä ýëåêòðîïèòàíèÿ,
îòñîåäèíèâ åãî îò ñåòè ýëåêòðîïèòàíèÿ.
Ïðîèçâîäèòåëü íå íåñåò îòâåòñòâåííîñòü çà âîçìîæíûé
óùåðá, âûçâàííûé: íåïðàâèëüíîé óñòàíîâêîé âàðî÷íîé
ïàíåëü, åå íåíàäëåæàùèì, íåïðàâèëüíûì èëè îïàñíûì
èñïîëüçîâàíèåì.
Ìîíòàæ âñòðàèâàåìûõ âàðî÷íûõ ïàíåëåé
Ïðèâåäåííûå íèæå èíñòðóêöèè ïðåäíàçíà÷åíû äëÿ
êâàëèôèöèðîâàííûõ ìîíòàæíèêîâ äëÿ íàèáîëåå
ïðàâèëüíîãî âûïîëíåíèÿ ìîíòàæà, ðåãóëÿöèè è
òåõíè÷åñêîãî îáñëóæèâàíèÿ ñ ñîáëþäåíèåì äåéñòâóþùèõ
íîðìàòèâîâ.
Âàæíî: ïåðåä íà÷àëîì êàêîé-ëèáî îïåðàöèè ïî ðåãóëÿöèè,
òåõíè÷åñêîìó îáñëóæèâàíèþ âàðî÷íîé ïàíåëè è ò.ä.
íåîáõîäèìî îòñîåäèíèòü åå îò ñåòè ýëåêòðîïèòàíèÿ.
Ðàñïîëîæåíèå
Âàæíî: äàííîå èçäåëèå ìîæåò áûòü óñòàíîâëåíî è
èñïîëüçîâàòüñÿ òîëüêî â ïîìåùåíèÿõ ñ ïîñòîÿííîé
âåíòèëÿöèåé â ñîîòâåòñòâèè ñ ïîëîæåíèÿìè äåéñòâóþùèõ
Íîðìàòèâîâ UNI-CIG 7129 è 7131. Íåîáõîäèìî ñîáëþäàòü
ñëåäóþùèå òðåáîâàíèÿ:
a) Â ïîìåùåíèè äîëæíà áûòü ïðåäóñìîòðåíà ñèñòåìà
äûìîóäàëåíèÿ â àòìîñôåðó â âèäå âûòÿæíîãî çîíòà èëè
ýëåêòðîâåíòèëÿòîðà, àâòîìàòè÷åñêè âêëþ÷àþùèõñÿ
êàæäûé ðàç, êîãäà âêëþ÷àåòñÿ èçäåëèå.
c) Èíòåíñèâíîå, ïðîäîëæèòåëüíîå èñïîëüçîâàíèåì
êóõîííîé òåõíèêè ìîæåò ïîòðåáîâàòü äîïîëíèòåëüíîé
âåíòèëÿöèè, íàïðèìåð, îòêðûòîå îêíî èëè áîëåå
ýôôåêòèâíóþ âåíòèëÿöèþ çà ñ÷åò ïîâûøåíèÿ ìîùíîñòè
ìåõàíè÷åñêîé âûòÿæêè, åñëè îíà èìååòñÿ.
d) Ñæèæåííûé ãàç ïðîïàí-áóòàí òÿæåëåå âîçäóõà è
ñëåäîâàòåëüíî çàñòàèâàåòñÿ âíèçó. Ïî ýòîé ïðè÷èíå
ïîìåùåíèÿ, â êîòîðûõ óñòàíîâëåíû áàëëîíû ñ
ÑÍÃ(ñæèæåííûì íàòóðàëüíûì ãàçîì) äîëæíû èìåòü
âåíòèëÿöèîííûå îòâåðñòèÿ, âûõîäÿùèå â àòìîñôåðó, äëÿ
óäàëåíèÿ ñíèçó âîçìîæíûõ óòå÷åê ãàçà. Ïîýòîìó áàëëîíû
ñ ÑÍà äîëæíû áûòü îïîðîæíåíû èëè îñòàâàòüñÿ ÷àñòè÷íî
çàïîëíåííûìè; îíè íå äîëæíû ðàçìåùàòüñÿ èëè õðàíèòüñÿ
â ïîìåùåíèÿõ èëè õðàíèëèùàõ, ðàñïîëîæåííûõ â
ïîäçåìíûõ ïîìåùåíèÿõ(ïîäâàëàõ, è ò.ä.). Ñëåäóåò äåðæàòü
â ïîìåùåíèè òîëüêî îäèí ðàáî÷èé áàëëîí, ðàñïîëîæåííûé
òàêèì îáðàçîì, ÷òîáû îí íå ïîäâåðãàëñÿ ïðÿìîìó
âîçäåéñòâèþ èñòî÷íèêîâ òåïëà(ïå÷åé, êàìèíîâ è ò.ä.),
êîòîðûå ìîãóò ïðèâåñòè ê íàãðåâó áàëëîíà ñâûøå50°C.
Ìîíòàæ âñòðàèâàåìûõ âàðî÷íûõ ïàíåëåé
Âàðî÷íàÿ ïàíåëü ìîæåò áûòü óñòàíîâëåíà ðÿäîì ñ
êóõîííûìè ýëåìåíòàìè, âûñîòà êîòîðûõ íå ïðåâûøàåò
ðàáî÷óþ ïîâåðõíîñòü âàðî÷íîé ïàíåëè. Ñòåíà, ïðèëåãàþùàÿ
ê çàäíåé ñòåíêå êóõîííîé ïëèòû, äîëæíà áûòü èç
íåâîçãîðàåìîãî ìàòåðèàëà. Â ïðîöåññå ðàáîòû êóõîííîé
ïëèòû åå çàäíÿÿ ñòåíêà ìîæåò äîñòèãíóòü òåìïåðàòóðû,
êîòîðàÿ íà 50°C ïðåâûøàåò òåìïåðàòóðó ïîìåùåíèÿ. Äëÿ
ïðàâèëüíîãî ìîíòàæà êóõîííîé ïëèòû íåîáõîäèìî
ñîáëþäàòü ñëåäóþùèå ìåðû ïðåäîñòîðîæíîñòè:
a) Êóõîííûå ýëåìåíòû, ðàñïîëîæåííûå ðÿäîì ñ êóõîííîé
ïëèòîé, âûñîòà êîòîðûõ ïðåâûøàåò óðîâåíü âàðî÷íîé
ïàíåëè, äîëæíû íàõîäèòüñÿ íà ðàññòîÿíèå íå ìåíåå 600
ìì îò êðàÿ âàðî÷íîé ïàíåëè.
b) Âûòÿæêà äîëæíà áûòü óñòàíîâëåíà â ñîîòâåòñòâèè ñ
ðóêîâîäñòâîì ïî ýêñïëóàòàöèè âûòÿæêè è â ëþáîì
ñëó÷àå íà âûñîòå íå ìåíåå 650 ìì.
c) Ðàñïîëîæèòå íàâåñíûå øêàôû, ïðèëåãàþùèå ê âûòÿæêå, íà
 êàìèí èëè â äûìîõîä ñ ìåäíûì ïîêðûòèåì
(äëÿ êóõîííûõ óñòðîéñòâ äëÿ ïðèãîòîâëåíèÿ
ïèùè)
Íåïîñðåäñòâåííî â
àòìîñôåðó
Äåòàëü À Ñìåæíîå
ïîìåùåíèå
Âåíòèëèðóåìîå
ïîìåùåíèå
Ïðèìåðû âåíòèëÿöèîííûõ
îòâåðñòèé äëÿ ïðèòîêà âîçäóõà
Ðèñ. À
Óâåëè÷åíèå ðàññòîÿíèÿ ìåæäó
äâåðüþ è ïîëîì.
Ðèñ. Â
A
b) Â ïîìåùåíèè äîëæíà áûòü ïðåäóñìîòðåíà ñèñòåìà,
îáåñïå÷èâàþùàÿ äîñòàòî÷íûé ïðèòîê âîçäóõà äëÿ
íàäëåæàùåãî ãîðåíèÿ. Ðàñõîä âîçäóõà, íåîáõîäèìûé äëÿ
ãîðåíèÿ, äîëæåí áûòü íå ìåíåå 2 ì3/÷àñ íà êÂò
óñòàíîâëåííîé ìîùíîñòè. Ñèñòåìà ïðèòîêà âîçäóõà ìîæåò
çàáèðàòü âîçäóõ íåïîñðåäñòâåííî èç àòìîñôåðû, ñíàðóæè
çäàíèÿ ÷åðåç âîçäóõîâîä ñ ïðîõîäíûì ñå÷åíèåì íå ìåíåå
100 ñì2, êîòîðûé íå ìîæåò áûòü ñëó÷àéíî çàñîðåí. Äëÿ
êóõîííîé áûòîâîé òåõíèêè, ðàáî÷àÿ ïîâåðõíîñòü êîòîðûõ
íå îñíàùåíà çàùèòíûì óñòðîéñòâîì íà ñëó÷àé îòñóòñòâèÿ
ïëàìåíè, ñå÷åíèå âåíòèëÿöèîííûõ îòâåðñòèé äîëæíî áûòü
óâåëè÷åíî íà 100%, ñ ìèíèìàëüíûì ñå÷åíèåì 200 ñì2 (Ðèñ.
À). Èëè æå âîçäóõ äëÿ ãîðåíèÿ ìîæåò ïîñòóïàòü èç
ïðèëåãàþùèõ ïîìåùåíèé, îñíàùåííûõ âåíòèëÿöèîííûì
îòâåðñòèåì, âûõîäÿùèì â àòìîñôåðó, êàê îïèñàíî âûøå,
ïðè óñëîâèè, ÷òî ýòè ïîìåùåíèÿ íå ÿâëÿþòñÿ
ïîæàðîîïàñíûìè èëè ñïàëüíÿìè (Ðèñ.Â).
Ðèñ. Ñ
d) Åñëè âàðî÷íàÿ ïàíåëü óñòàíàâëèâàåòñÿ ïîä íàâåñíûì
øêàôîì, ïîñëåäíèé äîëæåí ðàñïîëàãàòüñÿ íà âûñîòå íå
ìåíåå 700 ìì îò ïîâåðõíîñòè, êàê ïîêàçàíî íà Ðèñ. Ñ.
e) Ðàçìåðû íèøè êóõîííîãî ýëåìåíòà äîëæíû
ñîîòâåòñòâîâàòü ðàçìåðàì, óêàçàííûì íà ðèñóíêå.
Ñïåðåäè
HOOD
420
Min.
min.
650
mm. with hood
min.
700
mm. without hood
mm.
600
Min. mm.
420
Min. mm.
555 mm.
55 mm.
475 mm.
Ïåðåä êðåïëåíèåì âàðî÷íîé ïàíåëè ê êóõîííîé ðàáî÷åé
ïîâåðõíîñòè ïîëîæèòå ïðîêëàäêó (ïðèëàãàåòñÿ) ïî
ïåðèìåòðó âàðî÷íîé ïàíåëè, êàê ïîêàçàíî íà ðèñóíêå.
 êîìïëåêò êðåïåæêè âõîäÿò êðåïåæíûå êðþêè äëÿ
êðåïëåíèÿ âàðî÷íîé ïàíåëè íà êóõîííîé ðàáî÷åé
ïîâåðõíîñòè òîëùèíîé îò 20 äî 40 ìì. Äëÿ íàäåæíîãî
êðåïëåíèÿ âàðî÷íîé ïàíåëè ðåêîìåíäóåòñÿ
èñïîëüçîâàòü âñå ïðèëàãàþùèåñÿ êðþêè.
Ñõåìà êðåïëåíèÿ êðþêîâ
Ñçàäè
ÏÐÈÌÅ×ÀÍÈÅ: Èñïîëüçóéòå êðþêè èç êîìïëåêòà
«âñïîìîãàòåëüíûå ïðèíàäëåæíîñòè»
f)f) Åñëè âàðî÷íàÿ ïàíåëü íå óñòàíàâëèâàåòñÿ ñâåðõó
âñòðîåííîãî äóõîâîãî øêàôà, íåîáõîäèìî âñòàâèòü
äåðåâÿííóþ ïàíåëü â êà÷åñòâå èçîëÿöèè. Ýòà ïàíåëü
äîëæíà áûòü óñòàíîâëåíà íà ðàññòîÿíèè íå ìåíåå 20
ìì îò íèæíåé ÷àñòè âàðî÷íîé ïàíåëè.
Ïðèìå÷àíèå: Åñëè âàðî÷íàÿ ïàíåëü óñòàíàâëèâàåòñÿ
ñâåðõó âñòðîåííîãî äóõîâîãî øêàôà, ðåêîìåíäóåòñÿ
óñòàíîâèòü äóõîâîé øêàô íà äâà äåðåâÿííûõ áðóñêà. Åñëè
â íèøå ñïëîøíàÿ îïîðíàÿ ïîâåðõíîñòü, â çàäíåé ñòåíêå
íèøè äîëæåí èìåòüñÿ ïðîåì íå ìåíåå 45 õ 560 ìì.
560 mm.
45 mm.
Åñëè âàðî÷íàÿ ïàíåëü óñòàíàâëèâàåòñÿ ñâåðõó âñòðîåííîãî
äóõîâîãî øêàôà, íå îñíàùåííîãî ïðèíóäèòåëüíîé
îõëàäèòåëüíîé âåíòèëÿöèåé, äëÿ íàäëåæàùåé âåíòèëÿöèè
âíóòðè êóõîííîãî ýëåìåíòà íåîáõîäèìî ïðîäåëàòü
âåíòèëÿöèîííûå îòâåðñòèÿ äëÿ öèðêóëÿöèè âîçäóõà.
Ïðèìåðû âîçìîæíîãî ìîíòàæà ïîêàçàíû íà ðèñóíêàõ íèæå.
Ïîäñîåäèíåíèå ê ãàçîïðîâîäó
Ïîäñîåäèíåíèå èçäåëèÿ ê ãàçîïðîâîäó èëè ê ãàçîâîìó
áàëëîíó äîëæíî îñóùåñòâëÿòüñÿ â ñîîòâåòñòâèè ñ
Íîðìàòèâàìè UNI-CIG 7129 è 7131 òîëüêî ïîñëå ïðîâåðêè
ñîîòâåòñòâèÿ èçäåëèÿ òèïó ãàçà, ê êîòîðîìó îí
ïîäñîåäèíÿåòñÿ.  ñëó÷àå íåñîîòâåòñòâèÿ âûïîëíèòå
îïåðàöèè, îïèñàííûå â ïàðàãðàôå «Íàñòðîéêà íà
ðàçëè÷íûå òèïû ãàçà».  ñëó÷àå èñïîëüçîâàíèÿ ñæèæåííîãî
ãàçà èç áàëëîíà èñïîëüçóéòå ðåãóëÿòîðû äàâëåíèÿ,
ñîîòâåòñòâóþùèå Íîðìàòèâó UNI-CIG 7432.
Ïîëîæåíèå êðþêà äëÿ
ðàáî÷åé ïîâåðõíîñòè
H=40 ìì
Ïîëîæåíèå êðþêà äëÿ
ðàáî÷åé ïîâåðõíîñòè
H=30 ìì
âûñîòå íå ìåíåå 420 ìì îò ðàáî÷åé ïîâåðõíîñòè êóõíè (Ðèñ. C).
Ïîëîæåíèå êðþêà äëÿ
ðàáî÷àÿ ïîâåðõíîñòü H=20 ìì
14
Âàæíî:äëÿ íàäåæíîãî ôóíêöèîíèðîâàíèÿ, ðàöèîíàëüíîãî
èñïîëüçîâàíèÿ ýíåðãèè è áîëåå äëèòåëüíîãî ñðîêà ñëóæáû
ýëåêòðè÷åñêîãî èçäåëèÿ ïðîâåðüòå, ÷òîáû äàâëåíèå ïîäà÷è
ãàçà ñîîòâåòñòâîâàëî çíà÷åíèÿì, óêàçàííûì â òàáëèöå1
«Õàðàêòåðèñòèêè ãàçîâûõ êîíôîðîê è ôîðñóíîê».
Ïîäñîåäèíåíèå ïðè ïîìîùè òâåðäîé òðóáêè (ìåäíîé
èëè ñòàëüíîé)
Ïîäñîåäèíåíèå ê ãàçîïðîâîäó íå äîëæíî îêàçûâàòü êàêèõ-
ëèáî íàãðóçîê íà èçäåëèå. Íà ïîäàþùåì ãàçîïðîâîäå
èçäåëèÿ èìååòñÿ âðàùàþùååñÿ êîëåíî ñ óïëîòíèòåëüíîé
ïðîêëàäêîé. Ïðè íåîáõîäèìîñòè ïîâåðíóòü êîëåíî
îáÿçàòåëüíî íåîáõîäèìî çàìåíèòü óïëîòíèòåëüíóþ
ïðîêëàäêó (ïðèëàãàåòñÿ ê èçäåëèþ). Ïàòðóáîê ïîäà÷è ãàçà
â èçäåëèå èìååò öèëèíäðè÷åñêóþ íàðóæíóþ ðåçüáó 1/2 ãàç.
Ïîäñîåäèíåíèå ïðè ïîìîùè ãèáêîé òðóáêè èç
íåðæàâåþùåé ñòàëè ñî ñïëîøíûìè ñòåíêàìè ñ
ðåçüáîâûìè ñîåäèíåíèÿìè.
Ïàòðóáîê ïîäà÷è ãàçà â èçäåëèå èìååò öèëèíäðè÷åñêóþ
íàðóæíóþ ðåçüáó 1/2 ãàç. Èñïîëüçóéòå òîëüêî øëàíãè,
ñîîòâåòñòâóþùèå íîðìàòèâó UNI-CIG 9891, è
óïëîòíèòåëüíûå ïðîêëàäêè, ñîîòâåòñòâóþùèå íîðìàòèâó
UNI-CIG 9264. Ïðè óñòàíîâêå ýòèõ øëàíãîâ èõ äëèíà â
ñîñòîÿíèè ìàêñèìàëüíîãî ðàñòÿæåíèÿ íå äîëæíà
ïðåâûøàòü 2000 ìì. Ïî çàâåðøåíèè ïîäñîåäèíåíèÿ
ïðîâåðèòü, ÷òîáû ìåòàëëè÷åñêàÿ ãèáêàÿ òðóáêà íå êàñàëàñü
ïîäâèæíûõ ÷àñòåé èëè íå áûëà ñæàòà.
Ïðîâåðêà óïëîòíåíèÿ
ïî çàâåðøåíèè ïîäñîåäèíåíèÿ ïðîâåðüòå ïðî÷íîñòü
óïëîòíåíèÿ âñåõ ïàòðóáêîâ ïðè ïîìîùè ìûëüíîãî ðàñòâîðà,
íî íèêîãäà íå ïëàìåíåì.
Ýëåêòðè÷åñêîå ïîäñîåäèíåíèå
Âàðî÷íûå ïàíåëè, îñíàùåííûå òðåõïîëÿðíûì ïðîâîäîì
ýëåêòðîïèòàíèÿ, ðàñ÷èòàíû íà ôóíêöèîíèðîâàíèå ñ
ïåðåìåííûì òîêîì ñ íàïðÿæåíèåì è ÷àñòîòîé
ýëåêòðîïèòàíèÿ, óêàçàííûìè íà çàâîäñêîé òàáëè÷êå ñ
äàííûìè (ðàñïîëîæåííîé ñíèçó âàðî÷íîé ïàíåëè). Ïðîâîä
çàçåìëåíèÿ ïðîâîäà ýëåêòðîïèòàíèÿ âûäåëÿåòñÿ æåëòî-
çåëåíûì öâåòîì.  ñëó÷àå óñòàíîâêè âàðî÷íîé ïàíåëè
ñâåðõó äóõîâîãî øêàôà, âñòðîåííîãî â êóõîííûé ýëåìåíò,
ýëåêòðè÷åñêîå ïîäñîåäèíåíèå âàðî÷íîé ïàíåëè è äóõîâîãî
øêàôà äîëæíî âûïîëíÿòüñÿ ðàçäåëüíî ïî ïðè÷èíàì
áåçîïàñíîñòè, à òàê æå äëÿ ëåãêîãî ñúåìà äóõîâîãî øêàôà.
Ïîäñîåäèíåíèå ïðîâîäà èçäåëèÿ ê ñåòè
ýëåêòðîïèòàíèÿ
Ïîäñîåäèíèòå ê ïðîâîäó èçäåëèÿ ñòàíäàðòíóþ
ýëåêòðè÷åñêóþ âèëêó, ðàñ÷èòàííóþ íà íàãðóçêó, óêàçàííóþ
íà çàâîäñêîé òàáëè÷êå ñ äàííûìè.  ñëó÷àå ïðÿìîãî
ïîäñîåäèíåíèÿ ê ñåòè ýëåêòðîïèòàíèÿ íåîáõîäèìî
óñòàíîâèòü ìåæäó ýëåêòðîïðèáîðîì è ñåòüþ
ìíîãîïîëþñíûé âûêëþ÷àòåëü ñ ìèíèìàëüíûì ðàññòîÿíèåì
ìåæäó êîíòàêòàìè 3 ìì, ðàñ÷èòàííûé íà íàãðóçêó è
ñîîòâåòñòâóþùèé äåéñòâóþùèì íîðìàòèâàì (ïðîâîä
çàçåìëåíèÿ íå äîëæåí ïðåðûâàòüñÿ âûêëþ÷àòåëåì).
Ïðîâîä ýëåêòðîïèòàíèÿ äîëæåí ðàñïîëàãàòüñÿ òàêèì
îáðàçîì, ÷òîáû íè â êàêîé òî÷êå îí íå ïîäâåðãàëñÿ
íàãðåâàíèþ, ïðåâûøàþùåìó òåìïåðàòóðó ïîìåùåíèÿ íà
50°C.
Ïåðåä îñóùåñòâëåíèåì ýëåêòðè÷åñêîãî ïîäñîåäèíåíèÿ
íåîáõîäèìî ïðîâåðèòü ñëåäóþùåå:
îãðàíè÷èòåëüíûé êëàïàí è äîìàøíÿÿ ñèñòåìà äîëæíû
áûòü ðàñ÷èòàíû íà íàãðóçêó èçäåëèÿ (ñìîòðèòå
çàâîäñêóþ òàáëè÷êó ñ òåõíè÷åñêèìè äàííûìè);
Ñåòü ýëåêòðîïèòàíèÿ äîëæíà áûòü îñíàùåíà íàäåæíûì
çàçåìëåíèåì ñîãëàñíî íîðìàòèâàì è óêàçàíèÿì
çàêîíîäàòåëüñòâà;
Ýëåêòðè÷åñêàÿ ðîçåòêà èëè ìíîãîïîëþñíûé
âûêëþ÷àòåëü äîëæíû áûòü ëåãêîäîñòóïíû áåç
íåîáõîäèìîñòè ñúåìà âàðî÷íîé ïàíåëè.
ÏÐÈÌÅ×ÀÍÈÅ: íå èñïîëüçóéòå óäëèíèòåëè, ïåðåõîäíèêè
èëè àäàïòåðû, òàê êàê îíè ìîãóò âûçâàòü ïåðåãðåâ èëè
âîçãîðàíèå.
Ïîäãîòîâêà ê ðàçëè÷íûì òèïàì ãàçà
Äëÿ ïîäãîòîâêè âàðî÷íîé ïàíåëè ê òèïó ãàçà,
îòëè÷àþùåìóñÿ îò ãàçà, íà êîòîðûé âàðî÷íàÿ ïëèòà
ðàñ÷èòàíà èçíà÷àëüíî (óêàçàí íà ýòèêåòêå ñíèçó âàðî÷íîé
ïàíåëè èëè íà óïàêîâêå), íåîáõîäèìî çàìåíèòü ôîðñóíêè
êîíôîðîê ñëåäóþùèì îáðàçîì:
ñíèìèòå ñ âàðî÷íîé ïàíåëè îïîðíûå ðåøåòêè è âûíüòå
êîíôîðêè èç ñâîèõ ãíåçä.
îòâèíòèòå ôîðñóíêè ïðè ïîìîùè ïîëîãî ãàå÷íîãî êëþ÷à
7 ìì è çàìåíèòå èõ íà ôîðñóíêè, ðàñ÷èòàííûå íà íîâûé
òèï ãàçà (ñìîòðèòå òàáëèöó 1 «Õàðàêòåðèñòèêè êîíôîðîê
è ôîðñóíîê»).
âîññòàíîâèòü äåòàëè íà ñâîè ìåñòà, âûïîëíÿÿ îïåðàöèè
â îáðàòíîì ïîðÿäêå.
Ïî çàâåðøåíèè îïåðàöèè çàìåíèòå ñòàðóþ ýòèêåòêó
òàðèðîâàíèÿ íà íîâóþ, ñîîòâåòñòâóþùóþ íîâîìó òèïó
èñïîëüçóåìîãî ãàçà. Ýòèêåòêó ìîæíî çàêàçàòü â íàøèõ
Öåíòðàõ Òåõíè÷åñêîãî Îáñëóæèâàíèÿ.
Åñëè äàâëåíèå èñïîëüçóåìîãî ãàçà îòëè÷àåòñÿ îò
ïðåäóñìîòðåííîãî äàâëåíèÿ èëè âàðüèðóåò, íåîáõîäèìî
óñòàíîâèòü íà ïèòàþùåì ãàçîïðîâîäå ñîîòâåòñòâóþùèé
ðåãóëÿòîð äàâëåíèÿ (ñîãëàñíî íîðìàòèâó UNICIG 7430
«Ðåãóëÿòîð äëÿ êàíàëèçèðîâàííûõ ãàçîâ»).
Ðåãóëÿöèÿ ïåðâè÷íîãî âîçäóõà êîíôîðîê
Êîíôîðêè íå íóæäàþòñÿ â êàêîé-ëèáî ðåãóëÿöèè ïåðâè÷íîãî
âîçäóõà.
Ðåãóëÿöèÿ ìèíèìàëüíîãî ïëàìåíè
Ðåãóëÿöèÿ ìèíèìàëüíîãî ïëàìåíè
ïîâåðíèòå ðóêîÿòêó â ïîëîæåíèå ìèíèìàëüíîãî
ïëàìåíè;
ñíèìèòå ðóêîÿòêó è ïîâåðíèòå ðåãóëÿöèîííûé âèíò,
ðàñïîëîæåííûé âíóòðè èëè ðÿäîì ñî ñòåðæíåì êðàíà,
âïëîòü äî ïîëó÷åíèÿ ñòàáèëüíîãî ìàëîãî ïëàìåíè;
ÏÐÈÌÅ×ÀÍÈÅ: â ñëó÷àå èñïîëüçîâàíèÿ ñæèæåííîãî
ãàçà âèíò ðåãóëÿöèè äîëæåí áûòü çàâèí÷åí äî óïîðà.
ïðîâåðüòå, ÷òîáû ïðè ðåçêîì ïîâîðîòå ðóêîÿòêè èç
ïîëîæåíèÿ ìàêñèìàëüíîãî ïëàìåíè íà ìèíèìàëüíîå,
êîíôîðêè íå ãàñëè.
â èçäåëèÿõ, îñíàùåííûõ çàùèòíûì óñòðéîñòâîì
(òåðìîïàðà) â ñëó÷àå íåèñïðàâíîñòè èçäåëèÿ ñ
êîíôîðêàìè ïðè ìèíìàëüíîì ïîâûøåíèè ðàñõîäà
Ïî çàâåðøåíèè ðåãóëÿöèè óñòàíîâèòå íà ìåñòî ïëîìáû íà
îáâîäíîì ãàçîïðîâîäå
Õàðàêòåðèñòèêè ãàçîâûõ êîíôîðîê è ôîðñóíîê
* Ïðè 15°C è 1013 ìáàð ñóõîé ãàç
** Ïðîïàí Òåïëîòâîðíàÿ ñïîñîáíîñòü = 50,37 ÌÄæ/êã
*** Áóòàí Òåïëîòâîðíàÿ ñïîñîáíîñòü = 49,47 ÌÄæ/êã
Ïðèðîäíûé ãàç Òåïëîòâîðíàÿ ñïîñîáíîñòü = 37,78 ÌÄæ/ì3
Ãîðîäñêîé ãàç Òåïëîòâîðíàÿ ñïîñîáíîñòü = 15,87 ÌÄæ/ì3
(1) Òîëüêî äëÿ èçäåëèé, îñíàùåííûõ çàùèòíûì óñòðîéñòâîì ïðîòèâ óòå÷êè ãàçà (ññûëêà F).
Òàáëèöà 1 Ñæèæåííûé ãàç Ïðèðîäíûé ãàç
Kîíôîðêà Äèàìåòð
(ìì)
Òåïëîòâîðíàÿ
ñïîñîáíîñòü
êÂò (p.c.s.*)
Áàéïàñ
1/100
(ìì)
Ôîðñó-
íêà
1/100
Ðàñõîä* ã/÷àñ Ôîðñóíê-
à 1/100
Ðàñõîä*
ë/÷àñ
Ôîðñó-
íêà
1/100
Ðàñõîä*
ë/÷àñ
Íîìèí. Ñîêðà-
ù.
(1) (mm) *** ** (mm) (mm)
Áûñòðàÿ
(Áîëüøàÿ)(R)
100 3.00 0.70 41 39 86 218 214 116 286 143 286
Ïîëóáûñòðàÿ
(Ñðåäíÿÿ)(S)
75 1.65 0.40 30 28 64 120 118 96 157 105 157
Âñïîìîãàòåë-
üíàÿ (Ìàëàÿ)
(À)
55 1.00 0.40 30 28 50 73 71 71 95 80 95
Äàâëåíèå
ïîäà÷è
Íîìèíàëüíîå (ìáàð)
Ìèíèìàëüíîå (ìáàð)
Ìàêñèìàëüíîå (ìáàð)
28-30
20
35
37
25
45
20
17
25
13
6,5
18
Äàííîå èçäåëèå ñîîòâåòñòâóåò ñëåäóþùèì Äèðåêòèâàì Åâðîïåéñêîãî Ñîîáùåñòâà:
- 73/23/CEE îò 19/02/73 (Íèçêîå íàïðÿæåíèå) è ïîñëåäóþùèì èçìåíåíèÿì;
- 89/336/CEE îò 03.05.89 (Ýëåêòðîìàãíèòíàÿ ñîâìåñòèìîñòü) è ïîñëåäóþùèì èçìåíåíèÿì;
- 90/396/CEE îò 29.06.90 (Ãàç) è ïîñëåäóþùèì èçìåíåíèÿì;
- 93/68/CEE îò 22.07.93 è ïîñëåäóþùèì èçìåíåíèÿì.
CISTD 640...
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
