Indesit CISPH 640 M (IX) Guida utente

Marca: Indesit

Modello: CISPH 640 M (IX)

Tipo: Guida utente

Questo manuale è adatto anche per

A. Gas Burners

B. Support Grid for Cookware

C. Control Knobs for Gas Burners

D. Ignitor for Gas Burners (only on certain models)

E. Ignition Button for Gas Burners (only on certain

models)

F. Safety Device (only on certain models) - Activates if

the flame accidentally goes out (spills, drafts, etc.),

interrupting the delivery of gas to the burner.

How To Use Your Appliance

Close-up View

The position of the corresponding gas burner or electric

hot plate (if present) is indicated on each control knob.

Gas Burners

The burners differ in size and power. Choose the most

appropriate one for the diameter of the cookware being

used.

The burner can be regulated with the corresonding control

knob by using one of the following settings:

• Off

High

Low

To turn on one of the burners, place a lighted match or

lighter near the burner, press the knob all the way in and

turn in the counter-clockwise direction to the "High" setting.

On those models fitted with a safety device (F), the

knob must be pressed in for about 6 seconds until the

device that keeps the flame lighted warms up.

On those models fitted with an ignitor (D), the "E"

ignition button, identified by the symbol, must first be

pressed and then the corresponding knob pushed all the

way in and turned in the counter-clockwise direction to

the "High" setting.

Some models are equipped with an ignition switch

incorporated into the control knob. If this is the case, the

ignitor (D) is present, but not the "E" switch (the symbol

is located near each knob).

To light a burner, simply press the corresponding knob all

the way in and then turn it in the counter-clockwise

direction to the "High" setting, keeping it pressed in until

the burner lights.

Caution: If the burner accidently goes out, turn off the

gas with the control knob and try to light it again after

waiting at least 1 minute.

To turn off a burner, turn the knob in the clockwise

direction until it stops (it should be on the “•” setting).

Congratualtions on choosing an Ariston appliance, which you will find is dependable and easy to use. We recommend

that you read this manual for best performance and to extend the life of your appliance. Thank you.

Before cleaning or performing maintenance on your

appliance, disconnect it from the electrical power supply.

To extend the life of the cooktop, it is absolutely

indispensable that it be cleaned carefully and

thoroughly on a frequent basis, keeping in mind the

following:

• Do not use steam equipment to clean the appliance.

• The enameled parts and the glass top, if present, must

be washed with warm water without using abrasive

powders or corrosive substances which could ruin

them;

• The removable parts of the burners should be washed

frequently with warm water and soap, making sure to

remove caked-on substances;

• On cooktops with automatic ignition, the end of the

electronic ignition device must be cleaned carefully and

frequently, making sure that the gas holes are not

clogged;

• Stainless steel can be stained if it remains in contact

with highly calcareous water or aggressive detergents

(containing phosphorous) for an extended period of

time. It is recommended that these parts be rinsed

thoroughly with water and then dried well. It is also a

good idea to clean up any spills.

Greasing the Taps

The taps may jam in time or they may become difficult to

turn. If so, the tap itself must be replaced.

N.B.: This operation must be performed by a technician

authorised by the manufacturer.

How to Keep Your Cooktop in Shape

Practical Advise on Using the Burners

For best performance, follow these general guidelines:

• Use the appropriate cookware for each burner (see

table) in order to prevent the flame from reaching the

sides of the pot or pan;

• Alwasy use cookware with a flat bottom and keep the

lid on;

• When the contents come to a boil, turn the knob to

"Low".

Burner ø Cookware Diameter (cm)

Fast (R) 24 – 26

Reduced Fast (RR) 22 – 24

Semi Fast (S) 16 – 20

Auxiliary (A) 10 – 14

Triple Crown (TC) 24 – 26

To identify the type of burner, refer to the designs in the

section entitled, "Burner and Nozzle Specifications".

Practical Advice

Is there a problem?

Safety Is a Good Habit to Get Into

• This manual is for a class 3 built-in cooktop.

• This appliance is designed for non-professional use in

the home and its features and technical characteristics

must not be modified.

• These instructions are only valid for the countries the

symbols for which appear on the manual and the serial

plate.

• The electrical system of this appliance is safe only when

it is correctly connected to an adequate earthing

system, as required by current safety standards.

Prevent children and the disabled from coming into

contact or having access to the following, as they

are possible sources of danger:

- The controls and the appliance in general;

- The packaging (plastic bags, polystyrene, nails, etc.);

- The appliance, during and immediately after use given

the heat generated by its use;

- The appliance when no longer in installed (in this case,

all potentially dangerous parts must be made safe).

The following should be avoided:

- Touching the appliance with wet parts of the body;

- Using the appliance with bare feet;

- Pulling on the appliance or the power supply cord to

disconnect them from the electrical outlet;

- Improper and/or dangerous use;

- Obstructing the ventilation or heat dissipation slots;

- Allowing the power supply cord of small appliances to

come into contact with the hot parts of the cooktop;

- Exposure to atmospheric agents (rain, sun);

- Using flammable liquids nearby;

- Using adaptors, multiple outlet plugs and/or extensions;

- Using unstable or deformed cookware;

- Leaving the electric hobs on without cookware on top

of them;

- Closing the glass top (if present) while the gas burners

or electrical hot plates are still hot;

- Trying to install or repair the appliance without the

assistance of qualified personnel.

The assistance of qualified personnel must be called

upon in the following cases:

- Installation (in accordance with the manufacturer's

instructions);

- When in doubt about the operation of the appliance;

- Replacement of the electrical outlet becuase it is

incompatible with the plug.

Contact service centers authorized by the

manufacturer in the following cases:

- When in doubt about the condition of the appliance

after having removed the packing;

- Damage to or replacement of the power supply cord;

- In the case of a breakdown or malfunction: ask for

original spare parts.

It is recommended that you follow the guidelines

below:

- Only use the appliance to cook food, avoiding all other

uses;

The burner does not remain on when set to "Low".

Check to make sure that:

• The gas holes are not clogged.

• There are no draughts near the cooking surface.

• The minimum has been adjusted correctly (see the

section entitled, "Minimum Regulation").

The cookware is not stable.

Check to make sure that:

• The bottom of the cookware is perfectly flat.

• The cookware is centered correctly on the burner or

electric hot plate.

• The support grids have not been inverted.

If, despite all of these checks, the cooktop does not

function properly and problem persists, call the nearest

Merloni Elettrodomestici Customer Service Centre,

informing them of:

- The type of problem.

- The abbreviation used to identify the model (Mod. ...) as

indicated on the warranty.

Never call upon technicians not authorized by the

manufacturer, and refuse to accept spare parts that are

not original.

It may occur that the cooktop does not function or does

not function properly. Before calling customer service for

assistance, lets see what can be done.

First of all, check to see that there are no interruptions in

the gas and electrical supplies, and, in particular, that the

gas valves for the mains are open.

The burner does not light or the flame is not uniform

around the burner.

Check to make sure that:

• The gas holes on the burner are not clogged;

• All of the movable parts that make up the burner are

mounted correctly;

• There are no draughts around the cooking surface.

The flame does not stay lighted on the model with

the safety device.

Check to make sure that:

• You press the knob all the way in;

• You keep the knob pressed in long enough to activate

the safety device.

• The gas holes are not clogged in the area

corresponding to the safety device.

To maintain the EFFICIENCY and SAFETY of this appliance, we recommend:

• call only the Service Centers authorized by the manufacturer

• always use original Spare Parts

- Check the condition of the appliance after it has been

unpacked;

- Disconnect the appliance from the power supply in the

event of malfunction and always before cleaning or

maintenance;

- When not in use, disconnect the appliance from the

power supply and turn off the gas valve (if present);

- Always check to make sure that the control knobs are

on the “•”/”o” setting when the appliance is not in use;

- Cut the power supply cord after disconnecting it from

the electrical mains when you decide to no longer use

the appliance.

• The manufacturer will not be held liable for any

damages arising out of : incorrect installation or

improper, incorrect or unreasonable use..

Installation Instructions for built-in

The following instructions are intended for the installer so

that the installation and maintenance procedures may be

followed in the most professional and expert manner

possible. Important: Disconnect the appliance from the

electrical supply before performing any maintenance

or regulation upkeep work.

Positioning the Cooktop

Important: this unit may be installed and used only in

permanently ventilated rooms in accordance with British

Standard Codes Of Practice: B.S. 6172 / B.S. 5440, Par.

2 and B.S. 6891 Current Editions. The following

requirements must be observed:

a) The room must be fitted with a ventilation system which

vents smoke and gases from combustion to the outside.

This must be done by means of a hood or electric

ventilator that turns on automatically each time the hood

is operated.

In a chimney stack or branched flue. Directly to the Outside

(exclusively for cooking appliances)

b) The room must also allow for the influx of the air needed

for proper combustion. The flow of air for combustion

purposes must not be less than 2 m³/h per kW of installed

capacity. The supply of said air can be effected by means

of direct influx from the outside through a duct with a

inner cross section of at least 100 cm² which must not be

able to be accidentally blocked. Those appliances which

are not fitted with a safety device to prevent the flame

from accidentally going out must have a ventilation

opening twice the size otherwise required, i.e. a minimum

of 200cm² (Fig. A). Otherwise, the room can be vented

indirectly through adjacent rooms fitted with ventilation

ducts to the outside as described above, as long as the

adjacent rooms are not shared areas, bedrooms or

present the risk of fire (Fig. B).

Detail A Adjacent Room to be

Room Vented

Examples of ventilation holes Enlarging the ventilation slot

for comburant air. between window and floor.

Fig. A Fig. B

c) Intensive and prolonged use of the appliance may ne-

cessitate supplemental ventilation, e.g. opening a window

or increasing the power of the air intake system (if

present).

d) Liquidified petroleum gases are heavier than air and, as

a result, settle downwards. Rooms in which LPG tanks

are installed must be fitted with ventilation openings to

the outside in order to allow the gas to escape in the

event of a leak. Therefore, LPG tanks, whether empty or

partially full, must not be installed or stored in rooms or

spaces below ground level (cellars, ect.). It is also a good

idea to keep only the tank currently being used in the

room, making sure that it is not near sources of heat

(ovens, fireplaces, stoves, etc.) that could raise the internal

temperature of the tank above 50°C.

Installation of Built-in Cooktops

The appliance can be installed next to furniture units which

are no taller than the top of the cooker hob. The wall in

direct contact with the back panel of the cooker must be

made of non-flammable material. During operation the

back panel of the cooker could reach a temperature of

50°C above room temperature. For proper installation of

the cooker, the following precautions must be taken:

a) If the cabinet(s) located next to the cooktop are higher

than the cooktop itself, the cabinet(s) must be installed

at least 110 mm from the edge cooktop;

b) Hoods must be installed in accordance with the

instructions contained in the installation manual for the

hoods themselves, and no less than 650 mm from the

cooktop;

c) The cabinets installed next to the hood must be located

at a height of at least 420 mm from the top, (as shown

in Fig. C).

HOOD

420

Min.

min.

650

mm. with hood

min.

700

mm. without hood

mm.

600

Min. mm.

420

Min. mm.

Fig. C

d) Should the cooktop be installed directly under a

cupboard, the latter should be at least 700 mm

(millimetres) from the top, as shown in Fig. C.

e) The dimensions of the cutout for the appliance must

be those indicated in the figure D. Clamps are provided

to fasten the cooktop to counters measuring from 20

to 40 mm in thickness. To fasten the cooktop securely,

it is recommended that all the clamps be used.

555 mm

55 mm

475 mm

Fig. D

Fastening Clamps - Assembly Diagram

Clamp Position for Clamp Position for

H=30mm top H=40mm top

Front

Clamp Position for

H=20mm top Back

N.B: Use the clamps contained in the "accessory kit."

f) In the event the cooktop is not installed above a built-

in oven, a wood panel must be inserted as insulation.

This panel must be placed at least 20 mm from the

bottom of the cooktop itself.

Important: When installing the cooktop above a built-in

oven, the oven should be placed on two wooden strips; in

the case of a joining cabinet surface, remember to leave

a space of at least 45 x 560 mm at the back.

560 mm.

45 mm.

When installing the cooktop above a built-in oven without

forced ventilation, ensure that there are air inlets and

outlets for ventilating the interior of the cabinet adequately.

Gas Connection for Cooktop

The cooktop should be connected to the gas supply by an

authorized installer. During installation of this product it is

essential to fit an approved gas tap to isolate the supply

from the appliance for the convenience of any subsequent

removal or servicing. Connection of the appliance to the

gas mains or liquid gas tanks must be carried out

according to the safety standards currently in force, and

only after it is ascertained that it is suitable for the type of

gas to be used. If not, follow the instructions indicated in

the section entitled, “Adapting the Cooktop for Different

Types of Gas”. If the cooktop is to be connected to tanks

containing liquid gas, use pressure regulators that comply

with current safety standards.

Important: To insure that the appliance operates safety,

the gas is regulated correctly and your appliance lasts

over time, make sure that gas pressure levels comply with

the indications given in Table 1, “Nozzle and Burner

Specifications”.

Gas Connection to Non-flexible Pipe

(copper or steel)

Connection to the gas source must be done in such a way

as to not create any stress points at any part of the

appliance.

The appliance is fitted with an adjustable, "L" shaped

connector and a gasket for the attachment to the gas supply.

Should this connector have to be turned, the gasket must be

replaced (supplied with the appliance).

The gas feed connector to the appliance is a threaded,

male 1/2" connector for round gas pipe.

Gas Connection to Flexible Steel Pipe

The gas feed connector to the appliance is a threaded,

male 1/2" connector for round gas pipe. Only use pipes,

tubes and gaskets that comply with current safety codes.

The maximum length of the flexible pipes must not exceed

2000 mm. Once the connection has been made, ensure

that the flexible metal tube does not touch any moving

parts and is not crushed.

Check the Seal

Once the appliance has been installed, make sure all the

connections are properly sealed, using a soapy water

solution. Never use a flame.

Electrical Connection

The cooktops fitted with a tripolar electrical supply cord

are designed to be be used with alternating current

according to the indications on the rating plate located

under the cooktop. The earthing wire can be identified by

its yellow-green colour.

In the case of installation over a built-in electric oven,

the electrical connections for the cooktop and oven

should be independent, not only for safety purposes, but

also to facilitate removal of one or both in the future.

Electrical Connection for Gas Cooktop

Fit the supply cord with a standard plug for the demand

rate indicated on the rating plate or connect it directly to

the electrical mains. In the latter case, a single pole switch

must be placed between the appliance and the mains,

with a minimum opening between the contacts of 3 mm in

compliance with current safety codes (the earthing wire

must not be interrupted by the switch). The power supply

cord must be positioned so that it does not reach a tem-

perature in excess of 50°C above room temperature at

any point.

Before making the actual connection, make sure that:

• The fuse and electrical system can withstand the load

required by the appliance;

• That the electrical supply system is equiped with an

efficient earth hook-up according to the norms and

regulations prescribed by law;

• That the plug or switch is easily accessible.

Important: the wires in the mains lead are coloured in

accordance with the following code:

Green & Yellow - Earth

Blue - Neutral

Brown - Live

As the colours of the wires in the mains lead may not

correspond with the coloured markings identifying the

terminals in your plug, proceed as follows:

Connect the Green & Yellow wire to the terminal marked

“E” or or coloured Green or Green & Yellow.

Connect the Brown wire to the terminal marked “L” or

coloured Red.

Connect the Blue wire to the terminal marked “N” or

coloured Black.

Adapting the Cooktop for Different Types of Gas

To adapt the cooktop to a different type of gas than that

for which it was designed, (see the sticker under the hob

or on the packaging), the burner nozzles must be changed,

as follows:

• Remove the pan supports and slide the burners out of

the cooktop.

• Unscrew the nozzles using a 7mm socket wrench and

replace them with those for the new type of gas. (See

table 1, “Burner and Nozzle Specifications”).

• Reassemble the parts following the instructions in

reverse order.

• On completing the operation, replace the old rating label

with the one showing the new type of gas; the sticker

is available from our Service Centres.

If the gas pressure is different than that prescribed, a

pressure regulator must be installed at the source, in

compliance with national standards governing the use of

piped gas regulators.

Regulation of Air Supply to the Burner

The burners do not need a primary air regulator.

Minimum Regulation

Minimum regulation.

• Turn the gas valve to minimum.

• Remove the knob and turn the regulator screw

(positioned either on the side of the top or inside the

shaft) clockwise until the flame becomes small but

regular.

N.B.: In the case of liquid gas, the regulation screw must

be fully screwed in (clockwise).

• Make sure that, when the knob is turned rapidly high

to low, the flame does not go out.

• In the event of a malfunction on appliances with the

security device (thermocouple) when the gas supply

is set at minimum, increase the minimum supply levels

using the regulator screw.

Once the adjustment has been made, apply sealing wax,

or a suitable substitute, to the old seals on the by-pass.

Burners and Nozzle Specifications

PH 640...

Table 1 Liquid Gas Natural Gas

Burner Diameter

(mm)

Thermal Power

kW (p.c.s.*)

By-pass

1/100

(mm)

Nozzle

1/100

Flow*

g/h

Nozzle

1/100

Flow*

l/h

Nozzle

1/100

Flow*

l/h

Nom. Red. (1) (mm) *** ** (mm) (mm)

Fast

(Large) (R)

100 3.00 0.7 41 39 86 218 214 116 286 143 286

Reduced Fast

(RR)

100 2.60 0.70 41 39 80 189 186 110 248 135 248

Semi Fast

(Medium) (S)

75 1.65 0.4 30 28 64 120 118 96 157 105 157

Auxiliary

(Small) (A)

55 1.00 0.4 30 28 50 73 71 71 95 80 95

Triple Crown

(TC)

130 3.25 1.3 60 57 91 236 232 133 309 150 303

Supply

pressures

Nominal (mbar)

Minimum (mbar)

Maximum (mbar)

28-30

6,5

* At 15°C and 1013 mbar-dry gas

** Propane P.C.S. = 50.37 MJ/kg.

*** Butane P.C.S. = 49.47 MJ/kg.

Natural P.C.S. = 37.78 MJ/m

(1) Only for appliances with the security device (Ref. F).

PH 640MST...

The European Directive 2002/96/EC on Waste Electrical

and Electronic Equipment (WEEE), requires that old

household electrical appliances must not be disposed of

in the normal unsorted municipal waste stream. Old

appliances must be collected separately in order to

optimise the recovery and recycling of the materials they

contain and reduce the impact on human health and the

environment. The crossed out “wheeled bin” symbol on

the product reminds you of your obligation, that when you

dispose of the appliance it must be separately collected.

Consumers should contact their local authority or retailer

for information concerning the correct disposal of their old

appliance.

This appliance complies with the following European

Economic Community directives:

- 73/23/EEC of 19/02/73 (Low Voltage) and subsequent

modifications;

- 89/336/EEC of 03/05/89 (Electromagnetic

Compatibility) and subsequent modifications;

- 90/396/EEC of 29/06/90 (Gas) and subsequent

modifications;

- 93/68/EEC of 22/07/93 and subsequent modifications.

- 2002/96/EEC

Áëàãîäàðèì Âàñ çà âûáîð èçäåëèÿ Ariston, íàäåæíîãî è ïðîñòîãî â îáðàùåíèè. Äëÿ çíàêîìñòâà ñ èçäåëèåì, ñ

ïîðÿäêîì åãî îïòèìàëüíîé è äîëãîñðî÷íîé ýêñïëóàòàöèè, ðåêîìåíäóåì ïðî÷èòàòü äàííîå ðóêîâîäñòâî ïî

ýêñïëóàòàöèè. Áëàãîäàðèì çà âíèìàíèå

A. Ãàçîâûå ãîðåëêè

B. Îïîðíûå ðåøåòêè äëÿ êàñòðþëü

C. Ðóêîÿòêè ðåãóëÿöèè ãàçîâîé âàðî÷íîé ïàíåëè

D. Ñâå÷à çàæèãàíèÿ ãàçîâûé êîíôîðîê (èìååòñÿ

òîëüêî â íåêîòîðûõ ìîäåëÿõ)

E. Êíîïêà çàæèãàíèÿ ãàçîâûõ êîíôîðîê (èìååòñÿ

òîëüêî â íåêîòîðûõ ìîäåëÿõ)

F. Çàùèòíîå óñòðîéñòâî (èìååòñÿ òîëüêî â

íåêîòîðûõ ìîäåëÿõ) - Ñðàáàòûâàåò ïðè ñëó÷àéíîì

ãàøåíèè ïëàìåíè (âûêèïàíèå æèäêîñòåé èç

êàñòðþëü, ñêâîçíÿêè è ò.ä.), ïåðåêðûâàÿ ïîäà÷ó ãàçà

íà ãîðåëêó.

Íà êàæäîé ðóêîÿòêå ïîêàçàíî ïîëîæåíèå ãàçîâîé

êîíôîðêè èëè ýëåêòðè÷åñêîé ïëèòû (åñëè èìååòñÿ),

êîòîðîé äàííàÿ ðóêîÿòêà óïðàâëÿåò.

Ãàçîâûå ãîðåëêè

Êîíôîðêè èìåþò ðàçíóþ ìîùíîñòü è ðàçìåðý.

Âûáåðèòå êîíôîðêó, íàèáîëåå ñîîòâåòñòâóþùóþ

äèàìåòðó èñïîëüçóåìîé ïîñóäû.

Ïðè ïîìîùè ñîîòâåòñòâóþùèé ðóêîÿòêè ìîæíî

óñòàíîâèòü îäèí èç ñëåäóþùèõ ðåæèìîâ êîíôîðêè:

 Âûêëþ÷åíî

Ìàêñèìàëüíûé

Ìèíèìàëüíûé

Äëÿ çàæèãàíèÿ îäíîé èç êîíôîðîê, ïîäíåñèòå ê íåé

çàææåííóþ ñïè÷êó èëè çàæèãàëêó, íàæìèòå äî óïîðà è

ïîâåðíèòå ïðîòèâ ÷àñîâîé ñòðåëêè ñîîòâåòñòâóþùóþ

ðóêîÿòêó â ïîëîæåíèå ìàêñèìàëüíîãî ïëàìåíè.

Â ìîäåëÿõ, îñíàùåííûõ óñòðîéñòâîì

áåçîïàñíîñòè F, íåîáõîäèìî äåðæàòü ðóêîÿòêó

êîíôîðêè íàæàòîé ïðèìåðíî 6 ñåêóíä äî òåõ ïîð, ïîêà

íå íàãðååòñÿ óñòðîéñòâî, àâòîìàòè÷åñêè

ïîääåðæèâàþùåå ãîðåíèå ïëàìåíè.

Â ìîäåëÿõ, îñíàùåííûõ ñâå÷îé çàæèãàíèÿ D, äëÿ

çàæèãàíèÿ íóæíîé êîíôîðêè íåîáõîäèìî ñíà÷àëà

íàæàòü êíîïêó âêëþ÷åíèÿ E, îáîçíà÷åííóþ ñèìâîëîì

, çàòåì íàæàòü äî óïîðà è ïîâåðíóòü ïðîòèâ

÷àñîâîé ñòðåëêè ñîîòâåòñòâóþùóþ ðóêîÿòêó â

ïîëîæåíèå ìàêñèìàëüíîãî ïëàìåíè.

Íåêîòîðûå ìîäåëè îñíàùåíû ñèñòåìîé çàæèãàíèÿ,

âñòðîåííîé â ðóêîÿòêó. Â ýòîì ñëó÷àå èìååòñÿ ñâå÷à

çàæèãàíèÿ D, à íå êíîïêà E (ñèìâîë íàõîäèòñÿ

ðÿäîì ñ êàæäîé ðóêîÿòêîé).

Äëÿ âêëþ÷åíèÿ íóæíîé êîíôîðêè äîñòàòî÷íî íàæàòü

äî óïîðà ñîîòâåòñòâóþùóþ ðóêîÿòêó è ïîâåðíóòü åå

ïðîòèâ ÷àñîâîé ñòðåëêè â ïîëîæåíèå ìàêñèìàëüíîãî

ïëàìåíè, óäåðæèâàÿ åå íàæàòîé âïëîòü äî çàæèãàíèÿ

ïëàìåíè.

Ïðåäóïðåæäåíèå: ïðè ñëó÷àéíîì ãàøåíèè ïëàìåíè

êîíôîðêè ïîâåðíèòå ðóêîÿòêó óïðàâëåíèÿ â ïîëîæåíèå

âûêëþ÷åíî è ïîïûòàéòåñü âíîâü çàæå÷ü êîíôîðêó

òîëüêî ïî ïðîøåñòâèè íå ìåíåå 1 ìèíóòû.

Äëÿ âûêëþ÷åíèÿ êîíôîðêè ïîâåðíèòå ðóêîÿòêó ïî

÷àñîâîé ñòðåëêå âïëîòü äî ãàøåíèÿ ïëàìåíè

(ïîëîæåíèå, îáîçíà÷åííîå ñèìâîëîì «»).

Ïîðÿäîê ýêñïëóàòàöèè ãàçîâîé ïëèòû

Äåòàëüíûé âèä èçäåëèÿ

Ïåðåä íà÷àëîì êàêîé-ëèáî îïåðàöèè ïî îáñëóæèâàíèþ

èëè ÷èñòêå îòñîåäèíèòü èçäåëèå îò ñåòè

ýëåêòðîïèòàíèÿ.

Äëÿ äëèòåëüíîé ñëóæáû âàðî÷íîé ïàíåëè âàæíî

ðåãóëÿðíî ïðîèçâîäèòü åå òùàòåëüíóþ îáùóþ

÷èñòêó, ó÷èòûâàÿ ñëåäóþùåå:

· íå èñïîëüçóéòå äëÿ ÷èñòêè ïàðîâûå àãðåãàòû

 ìîéòå ýìàëèðîâàííûå ÷àñòè è ñòåêëÿííóþ êðûøêó,

åñëè èìåþòñÿ, òåïëîé âîäîé áåç èñïîëüçîâàíèÿ

àáðàçèâíûõ ïîðîøêîâ è êîððîçèéíûõ ìîþùèõ

ñðåäñòâ, êîòîðûå ìîãóò ïîâðåäèòü òàêèå

ïîâåðõíîñòè;

 íåîáõîäèìî ðåãóëÿðíî ìûòü ñúåìíûå ÷àñòè

êîíôîðîê ãîðÿ÷åé âîäîé ñ ìîþùèì ñðåäñòâîì,

òùàòåëüíî óäàëÿÿ âñå âîçìîæíûå íàëåòû;

 íà âàðî÷íûõ ïàíåëÿõ, îñíàùåííûõ àâòîìàòè÷åñêèì

çàæèãàíèåì, ñëåäóåò ðåãóëÿðíî ÷èñòèòü

íàêîíå÷íèêè óñòðîéñòâ ìãíîâåííîãî ýëåêòðîííîãî

çàæèãàíèÿ è ïðîâåðÿòü, ÷òîáû îòâåðñòèÿ ãàçîâûõ

êîíôîðîê íå áûëè çàñîðåíû;

 íà äåòàëÿõ èç íåðæàâåþùåé ñòàëè ìîãóò

îáðàçîâàòüñÿ ïÿòíà, åñëè îíè îñòàþòñÿ â òå÷åíèå

äëèòåëüíîãî âðåìåíè â êîíòàêòå ñ âîäîé

ïîâûøåííîé æåñòêîñòè èëè ñ àãðåññèâíûìè

ìîþùèìè ñðåäñòâàìè (ñîäåðæàùèìè ôîñôîð).

Ïîñëå ÷èñòêè ðåêîìåíäóåòñÿ òùàòåëüíî óäàëèòü

îñòàòêè ìîþùåãî ñðåäñòâà âëàæíîé òðÿïêîé è

âûñóøèòü. Êðîìå òîãî ñëåäóåò íåçàìåäëèòåëüíî

óäàëÿòü âîçìîæíûå óòå÷êè âîäû.

Óõîä çà ðóêîÿòêàìè êîíôîðîê

Ñî âðåìåíåì ðóêîÿòêè ïëèòû ìîãóò çàáëîêèðîâàòüñÿ

èëè âðàùàòüñÿ ñ òðóäîì, ïîýòîìó ïîòðåáóåòñÿ

ïðîèçâåñòè èõ âíóòðåííþþ ÷èñòêó è çàìåíó âñåé

ðóêîÿòêè.

ÏÐÈÌÅ×ÀÍÈÅ: Äàííàÿ îïåðàöèÿ äîëæíà

âûïîëíÿòüñÿ òåõíèêîì, óïîëíîìî÷åííûì

ïðîèçâîäèòåëåì.

Óõîä çà âàðî÷íîé ïàíåëüþ

Ïðàêòè÷åñêèå ñîâåòû ïî ýêñïëóàòàöèè ãàçîâûõ

êîíôîðîê

Äëÿ ìàêñèìàëüíîé îòäà÷è ñëåäóåò ïîìíèòü:

 äëÿ êàæäîé êîíôîðêè èñïîëüçóéòå ïîäõîäÿùóþ

ïîñóäó (ñìîòðè òàáëèöó) ñ òåì, ÷òîáû ïëàìÿ

êîíôîðêè íå âûõîäèëî èç-ïîä äíà ïîñóäû.

 âñåãäà èñïîëüçóéòå ïîñóäó ñ ïëîñêèì äíîì è ñ

êðûøêîé.

 â ìîìåíò çàêèïàíèÿ ïîâåðíèòå ðóêîÿòêó ïëèòû â

ïîëîæåíèå ìàëîãî ïëàìåíè.

Ðåêîìåíäàöèè ïî ýêñïëóàòàöèè

Äëÿ îïðåäåëåíèÿ òèïà êîíôîðêè ñìîòðèòå ðèñóíêè â

ïàðàãðàôå «Õàðàêòåðèñòèêè êîíôîðîê è ôîðñóíîê».

Kîíôîðêà ø Äèàìåòð êàñòðþëè (ñì)

Áûñòðàÿ

(Áîëüøàÿ)(R)

24  26

Áûñòðàÿ

ñîêðàùåííàÿ (RR)

22  24

Ñðåäíÿÿ (S) 16  20

Ìàëàÿ (À) 10  14

Òðîéíàÿ (ÒÑ) 24  26

×òî äåëàòü, åñëè âàðî÷íàÿ ïàíåëü ðàáîòàåò

íåèñïðàâíî èëè íå ðàáîòàåò âîâñå. Ïåðåä òåì êàê

îáðàòèòüñÿ â öåíòð òåõíè÷åñêîãî îáñëóæèâàíèÿ,

ñëåäóåò ñàìîñòîÿòåëüíî ïðîèçâåñòè ñëåäóþùèå

ïðîâåðêè.

Ïðåæäå âñåãî ñëåäóåò ïðîâåðèòü, ÷òîáû íè â ñåòè

ýëåêòðîïèòàíèÿ, íè íà ãàçîïðîâîäå íå áûëî ðàçðûâîâ,

è â ÷àñòíîñòè, ÷òîáû îáùèé ãàçîâûé êðàí áûë îòêðûò.

Êîíôîðêà íå çàæèãàåòñÿ, èëè ïëàìÿ ãîðèò

íåðàâíîìåðíî.

Ïðîâåðüòå ñëåäóþùåå:

 Ôîðñóíêè ãàçîâîé êîíôîðêè íå äîëæíû áûòü

çàñîðåíû.

 Âñå ïîäâèæíûå ÷àñòè êîíôîðêè äîæíû áûòü

óñòàíîâëåíû ïðàâèëüíî.

 Ðÿäîì ñ ãàçîâîé âàðî÷íîé ïàíåëüþ íå äîëæíî áûòü

ñêâîçíÿêîâ.

Â ìîäåëÿõ ïëèòû, îñíàùåííûõ çàùèòíûì

óñòðîéñòâîì, êîíôîðêà çàãîðàåòñÿ è ñðàçó ãàñíåò.

Ïðîâåðüòå ñëåäóþùåå:

 Ðóêîÿòêà êîíôîðêè íàæàòà íå äî óïîðà.

 Ðóêîÿòêà áûëà íàæàòà â òå÷åíèå âðåìåíè,

íåäîñòàòî÷íîãî äëÿ âêëþ÷åíèÿ çàùèòíîãî

óñòðîéñòâà.

 Çàñîðåíû ôîðñóíêè ãàçîâîé êîíôîðêè,

ðàñïîëîæåííûå íàïðîòèâ çàùèòíîãî óñòðîéñòâà.

Êîíôîðêà ãàñíåò â ïîëîæåíèè ìàëîãî ïëàìåíè.

Ïðîâåðüòå ñëåäóþùåå:

 Çàñîðåíû ôîðñóíêè ãàçîâîé êîíôîðêè.

 Ðÿäîì ñ ãàçîâîé âàðî÷íîé ïàíåëüþ íå äîëæíî áûòü

ñêâîçíÿêîâ.

 Íåïðàâèëüíàÿ ðåãóëÿöèÿ ìàëîãî ïëàìåíè

(Ñìîòðèòå ïàðàãðàô «Ðåãóëÿöèÿ ìàëîãî ïëàìåíè»).

Íåñòàáèëüíûå êàñòðþëè

Ïðîâåðüòå ñëåäóþùåå:

 Äíî êàñòðþëè äîëæíî áûòü èäåàëüíî ïëîñêèì.

 Êàñòðþëÿ äîëæíà áûòü óñòàíîâëåíà ïî öåíòðó

ãàçîâîé èëè ýëåêòðè÷åñêîé êîíôîðêè.

 Îïîðíûå ðåøåòêè íà âàðî÷íîé ïàíåëè óñòàíîâëåíû

íåïðàâèëüíî.

Åñëè íåñìîòðÿ íà âñå ïðîâåðêè âàðî÷íàÿ ïàíåëü íå

ðàáîòàåò, è îáíàðóæåííàÿ íåèñïðàâíîñòü íå óñòðàíÿåòñÿ,

îáðàòèòåñü â áëèæàéøèé Öåíòð òåõíè÷åñêîãî

îáñëóæèâàíèÿ Merloni Elettrodomestici, èìåÿ ïîä ðóêîé

ñëåäóþùèå äàííûå:

- îïèñàíèå íåèñïðàâíîñòè.

- Êîä ìîäåëè (Ìîä. ...) óêàçàííûé â ãàðàíòèéíîì

ñåðòèôèêàòå.

Íèêîãäà íå îáðàùàéòåñü ê íåóïîëíîìî÷åííûì

òåõíèêàì è íå äîïóñêàéòå óñòàíîâêè íåîðèãèíàëüíûõ

çàïàñíûõ ÷àñòåé.

×òî äåëàòü â ñëó÷àå âîçíèêíîâåíèÿ íåèñïðàâíîñòåé

Õîðîøåå ïðàâèëî - áåçîïàñíîñòü

 Äàííîå òåõíè÷åñêîå ðóêîâîäñòâî îòíîñèòñÿ ê

âñòðàèâàåìîé âàðî÷íîé ïàíåëè êëàññà 3.

 Äàííîå èçäåëèå ïðåäíàçíà÷àåòñÿ äëÿ

íåïðîôåññèîíàëüíîãî èñïîëüçîâàíèÿ â äîìàøíèõ

óñëîâèÿ, è åãî õàðàêòåðèñòèêè íå äîëæíû èçìåíÿòüñÿ.

 Äàííûå èíñòðóêöèè äåéñòâèòåëüíû òîëüêî â òåõ ñòðàíàõ,

îáîçíà÷åíèÿ êîòîðûõ ïðèâîäÿòñÿ â òåõíè÷åñêîì

ðóêîâîäñòâå è íà çàâîäñêîé òàáëè÷êå.

 Ýëåêòðè÷åñêàÿ áåçîïàñíîñòü äàííîãî èçäåëèÿ

ãàðàíòèðóåòñÿ, òîëüêî åñëè îíî áóäåò ïðàâèëüíî

ïîäñîåäèíåíî ê íàäëåæàùåé ñèñòåìå çàçåìëåíèÿ â

ñîîòâåòñòâèè ñ äåéñòâóþùèìè íîðìàòèâàìè ïî

áåçîïàñíîñòè.

Òàê êàê ãàçîâàÿ âàðî÷íàÿ ïàíåëü ÿâëÿåòñÿ èñòî÷íèêîì

îïàñíîñòè, íå äîïóñêàòü äåòåé è èíâàëèäîâ ê:

- ãàçîâîé âàðî÷íîé ïàíåëè è ê åå ðåãóëÿöèÿì;

- óïàêîâî÷íûì ìàòåðèàëàì (ïàêåòàì, ïîëèñòèðîëó,

ãâîçäÿì è ò.ä.);

- ãàçîâîé âàðî÷íîé ïàíåëè â ïðîöåññå èëè ñðàçó æå ïîñëå

åå ýêñïëóàòàöèè âî èçáåæàíèå îæåãîâ;

- âûêëþ÷åííîé âàðî÷íîé ïàíåëè (â äàííîì ñëó÷àå

íåîáõîäèìî îáåçîïàñèòü âñå ïîòåíöèàëüíî îïàñíûå

êîìïîíåíòû).

Èçáåãàéòå ñëåäóþùèõ äåéñòâèé:

- íå ïðèêàñàéòåñü ê âàðî÷íîé ïàíåëè ìîêðûìè ÷àñòÿìè

òåëà:

- íå ïîëüçóéòåñü âàðî÷íîé ïàíåëüþ áîñèêîì;

- íå òÿíèòå çà ïðîâîä ýëåêòðîïèòàíèÿ èëè çà ñàìó

âàðî÷íóþ ïàíåëü äëÿ åå îòñîåäèíåíèÿ îò ñåòè

ýëåêòðîïèòàíèÿ;

- èçáåãàéòå íåóìåñòíûõ è îïàñíûõ äåéñòâèé;

- íå çàêðûâàéòå âåíòèëÿöèîííûå îòâåðñòèÿ èëè

îòâåðñòèÿ äëÿ ðàññåèâàíèÿ òåïëà;

- ýë. ïðîâîäà ðàçëè÷íûõ äîìàøíèõ ýëåêòðîïðèáîðîâ íå

äîëæíû êàñàòüñÿ ãîðÿ÷èõ ÷àñòåé âàðî÷íîé ïàíåëè;

- íà âàðî÷íóþ ïàíåëü íå äîëæíû âîçäåéñòâîâàòü

àòìîñôåðíûå ÿâëåíèÿ (äîæäü, ñîëíöå);

- íå èñïîëüçóéòå ãîðþ÷èå æèäêîñòè ðÿäîì ñ âàðî÷íîé

ïàíåëüþ;

- íå èñïîëüçóéòå ïåðåõîäíèêè, òðîéíèêè è/èëè

óäëèíèòåëè;

- íå èñïîëüçóéòå íåñòàáèëüíûå èëè äåôîðìèðîâàííûå

êàñòðþëè;

- íå îñòàâëÿéòå âêëþ÷åííûìè ýëåêòðè÷åñêèå êîíôîðêè

áåç ïîñóäû;

- íå çàêðûâàéòå ñòåêëÿííîé êðûøêîé (åñëè îíà èìååòñÿ)

íåîñòûâøèå ãàçîâûå èëè ýëåêòðè÷åñêèå êîíôîðêè;

- íå ïûòàéòåñü ïðîèçâåñòè óñòàíîâêó èëè ðåìîíò ïëèòû

ñàìîñòîÿòåëüíî, áåç ñîäåéñòâèÿ êâàëèôèöèðîâàííîãî

ïåðñîíàëà.

Â ñëåäóþùèõ ñëó÷àÿõ íåîáõîäèìî îáðàòèòüñÿ ê

êâàëèôèöèðîâàííîìó ïåðñîíàëó â îáÿçàòåëüíîì

ïîðÿäêå:

- óñòàíîâêà (â ñîîòâåòñòâèè ñ èíñòðóêöèÿìè

ïðîèçâîäèòåëÿ);

- â ñëó÷àå ñîìíåíèé êàñàòåëüíî èñïðàâíîãî

ôóíêöèîíèðîâàíèÿ âàðî÷íîé ïàíåëè;

Äëÿ îáåñïå÷åíèÿ ýôôåêòèâíîé è áåçîïàñíîé ýêñïëóàòàöèè äàííîãî áûòîâîãî ýëåêòðîïðèáîðà:

 îáðàùàéòåñü òîëüêî â óïîëíîìî÷åííûå öåíòðû òåõíè÷åñêîãî îáñëóæèâàíèÿ

 âñåãäå òðåáóéòå óñòàíîâêó îðèãèíàëüíûõ çàïàñíûõ ÷àñòåé

- äëÿ çàìåíû ýë. ðîçåòêè â ñëó÷àå åå íåñîâìåñòèìîñòè ñ

ýë. âèëêîé âàðî÷íîé ïàíåëè.

Â ñëåäóþùèõ ñëó÷àÿõ íåîáõîäèìî îáðàòèòüñÿ â

óïîëíîìî÷åííûå öåíòðû òåõíè÷åñêîãî îáñëóæèâàíèÿ:

- â ñëó÷àå ñîìíåíèÿ êàñàòåëüíî öåëîñòíîñòè âàðî÷íîé

ïàíåëè ïîñëå åå ðàñïàêîâêè;

- â ñëó÷àå ïîâðåæäåíèÿ èëè çàìåíû ïðîâîäà

ýëåêòðîïèòàíèÿ;

- â ñëó÷àå íåèñïðàâíîñòè èëè ïëîõîãî ôóíêöèîíèðîâàíèÿ

èçäåëèÿ, çàïðàøèâàÿ óñòàíîâêó îðèãèíàëüíûõ çàïàñíûõ

÷àñòåé.

Ðåêîìåíäóåìûå îïåðàöèè:

- èñïîëüçóéòå âàðî÷íóþ ïàíåëü èñêëþ÷èòåëüíî äëÿ

ïðèãîòîâëåíèÿ ïèùè, èçáåãàÿ åå èñïîëüçîâàíèÿ â èíûõ

öåëÿõ;

- ïðîâåðüòå öåëîñòíîñòü âàðî÷íîé ïàíåëè, ñíÿâ ñ íåå

óïàêîâêó;

- â ñëó÷àå íåèñïðàâíîãî ôóíêöèîíèðîâàíèÿ âàðî÷íîé

ïàíåëè è ïåðåä îñóùåñòâëåíèåì êàêîé-ëèáî îïåðàöèè

ïî åå òåõíè÷åñêîìó îáñëóæèâàíèþ èëè ÷èñòêè

íåîáõîäèìî îòñîåäèíèòü ïàíåëü îò ñåòè ýëåêòðîïèòàíèÿ;

- â ñëó÷àå ïðîñòîÿ íåîáõîäèìî îòñîåäèíèòü âàðî÷íóþ

ïàíåëü îò ñåòè ýëåêòðîïèòàíèÿ è ïåðåêðûòü êðàí ïîäà÷è

ãàçà (åñëè îí ïðåäóñìîòðåí);

- âñåãäà ïðîâåðÿéòå, ÷òîáû ðóêîÿòêè íàõîäèëèñü â

ïîëîæåíèè /o, êîãäà èçäåëèå íå èñïîëüçóåòñÿ;

- ïî îêîí÷àíèè ñðîêà ñëóæáû âàðî÷íîé ïàíåëü

íåîáõîäèìî îòðåçàòü ïðîâîä ýëåêòðîïèòàíèÿ,

îòñîåäèíèâ åãî îò ñåòè ýëåêòðîïèòàíèÿ.

 Ïðîèçâîäèòåëü íå íåñåò îòâåòñòâåííîñòü çà âîçìîæíûé

óùåðá, âûçâàííûé: íåïðàâèëüíîé óñòàíîâêîé âàðî÷íîé

ïàíåëü, åå íåíàäëåæàùèì, íåïðàâèëüíûì èëè îïàñíûì

èñïîëüçîâàíèåì.

Ìîíòàæ âñòðàèâàåìûõ âàðî÷íûõ ïàíåëåé

Ïðèâåäåííûå íèæå èíñòðóêöèè ïðåäíàçíà÷åíû äëÿ

êâàëèôèöèðîâàííûõ ìîíòàæíèêîâ äëÿ íàèáîëåå ïðàâèëüíîãî

âûïîëíåíèÿ ìîíòàæà, ðåãóëÿöèè è òåõíè÷åñêîãî îáñëóæèâàíèÿ ñ

ñîáëþäåíèåì äåéñòâóþùèõ íîðìàòèâîâ.

Âàæíî: ïåðåä íà÷àëîì êàêîé-ëèáî îïåðàöèè ïî ðåãóëÿöèè,

òåõíè÷åñêîìó îáñëóæèâàíèþ âàðî÷íîé ïàíåëè è ò.ä. íåîáõîäèìî

îòñîåäèíèòü åå îò ñåòè ýëåêòðîïèòàíèÿ.

Ðàñïîëîæåíèå

Âàæíî: äàííîå èçäåëèå ìîæåò áûòü óñòàíîâëåíî è

èñïîëüçîâàòüñÿ òîëüêî â ïîìåùåíèÿõ ñ ïîñòîÿííîé âåíòèëÿöèåé

â ñîîòâåòñòâèè ñ ïîëîæåíèÿìè äåéñòâóþùèõ Íîðìàòèâîâ.

Íåîáõîäèìî ñîáëþäàòü ñëåäóþùèå òðåáîâàíèÿ:

a) Â ïîìåùåíèè äîëæíà áûòü ïðåäóñìîòðåíà ñèñòåìà

äûìîóäàëåíèÿ â àòìîñôåðó â âèäå âûòÿæíîãî çîíòà èëè

ýëåêòðîâåíòèëÿòîðà, àâòîìàòè÷åñêè âêëþ÷àþùèõñÿ êàæäûé

ðàç, êîãäà âêëþ÷àåòñÿ èçäåëèå.

b) Â ïîìåùåíèè äîëæíà áûòü ïðåäóñìîòðåíà ñèñòåìà,

îáåñïå÷èâàþùàÿ äîñòàòî÷íûé ïðèòîê âîçäóõà äëÿ

íàäëåæàùåãî ãîðåíèÿ. Ðàñõîä âîçäóõà, íåîáõîäèìûé äëÿ

ãîðåíèÿ, äîëæåí áûòü íå ìåíåå 2 ì3/÷àñ íà êÂò óñòàíîâëåííîé

ìîùíîñòè. Ñèñòåìà ïðèòîêà âîçäóõà ìîæåò çàáèðàòü âîçäóõ

íåïîñðåäñòâåííî èç àòìîñôåðû, ñíàðóæè çäàíèÿ ÷åðåç

âîçäóõîâîä ñ ïðîõîäíûì ñå÷åíèåì íå ìåíåå 100 ñì2, êîòîðûé

íå ìîæåò áûòü ñëó÷àéíî çàñîðåí. Äëÿ êóõîííîé áûòîâîé

òåõíèêè, ðàáî÷àÿ ïîâåðõíîñòü êîòîðûõ íå îñíàùåíà

çàùèòíûì óñòðîéñòâîì íà ñëó÷àé îòñóòñòâèÿ ïëàìåíè,

ñå÷åíèå âåíòèëÿöèîííûõ îòâåðñòèé äîëæíî áûòü óâåëè÷åíî

íà 100%, ñ ìèíèìàëüíûì ñå÷åíèåì 200 ñì2 (Ðèñ. À). Èëè æå

âîçäóõ äëÿ ãîðåíèÿ ìîæåò ïîñòóïàòü èç ïðèëåãàþùèõ

ïîìåùåíèé, îñíàùåííûõ âåíòèëÿöèîííûì îòâåðñòèåì,

âûõîäÿùèì â àòìîñôåðó, êàê îïèñàíî âûøå, ïðè óñëîâèè,

÷òî ýòè ïîìåùåíèÿ íå ÿâëÿþòñÿ ïîæàðîîïàñíûìè èëè

ñïàëüíÿìè (Ðèñ.Â).

c) Èíòåíñèâíîå, ïðîäîëæèòåëüíîå èñïîëüçîâàíèåì êóõîííîé

òåõíèêè ìîæåò ïîòðåáîâàòü äîïîëíèòåëüíîé âåíòèëÿöèè,

íàïðèìåð, îòêðûòîå îêíî èëè áîëåå ýôôåêòèâíóþ

âåíòèëÿöèþ çà ñ÷åò ïîâûøåíèÿ ìîùíîñòè ìåõàíè÷åñêîé

âûòÿæêè, åñëè îíà èìååòñÿ.

d)Ñæèæåííûé ãàç ïðîïàí-áóòàí òÿæåëåå âîçäóõà è ñëåäîâàòåëüíî

çàñòàèâàåòñÿ âíèçó. Ïî ýòîé ïðè÷èíå ïîìåùåíèÿ, â êîòîðûõ

óñòàíîâëåíû áàëëîíû ñ ÑÍÃ(ñæèæåííûì íàòóðàëüíûì ãàçîì)

äîëæíû èìåòü âåíòèëÿöèîííûå îòâåðñòèÿ, âûõîäÿùèå â

àòìîñôåðó, äëÿ óäàëåíèÿ ñíèçó âîçìîæíûõ óòå÷åê ãàçà.

Ïîýòîìó áàëëîíû ñ ÑÍÃ äîëæíû áûòü îïîðîæíåíû èëè

îñòàâàòüñÿ ÷àñòè÷íî çàïîëíåííûìè; îíè íå äîëæíû

ðàçìåùàòüñÿ èëè õðàíèòüñÿ â ïîìåùåíèÿõ èëè õðàíèëèùàõ,

ðàñïîëîæåííûõ â ïîäçåìíûõ ïîìåùåíèÿõ(ïîäâàëàõ, è ò.ä.).

Ñëåäóåò äåðæàòü â ïîìåùåíèè òîëüêî îäèí ðàáî÷èé áàëëîí,

ðàñïîëîæåííûé òàêèì îáðàçîì, ÷òîáû îí íå ïîäâåðãàëñÿ

ïðÿìîìó âîçäåéñòâèþ èñòî÷íèêîâ òåïëà(ïå÷åé, êàìèíîâ è ò.ä.),

êîòîðûå ìîãóò ïðèâåñòè ê íàãðåâó áàëëîíà ñâûøå50°C.

Ìîíòàæ âñòðàèâàåìûõ âàðî÷íûõ ïàíåëåé

Âàðî÷íàÿ ïàíåëü ìîæåò áûòü óñòàíîâëåíà ðÿäîì ñ êóõîííûìè

ýëåìåíòàìè, âûñîòà êîòîðûõ íå ïðåâûøàåò ðàáî÷óþ ïîâåðõíîñòü

âàðî÷íîé ïàíåëè. Ñòåíà, ïðèëåãàþùàÿ ê çàäíåé ñòåíêå êóõîííîé

ïëèòû, äîëæíà áûòü èç íåâîçãîðàåìîãî ìàòåðèàëà. Â ïðîöåññå

ðàáîòû êóõîííîé ïëèòû åå çàäíÿÿ ñòåíêà ìîæåò äîñòèãíóòü

òåìïåðàòóðû, êîòîðàÿ íà 50°C ïðåâûøàåò òåìïåðàòóðó

ïîìåùåíèÿ. Äëÿ ïðàâèëüíîãî ìîíòàæà êóõîííîé ïëèòû íåîáõîäèìî

Äåòàëü À

Ñìåæíîå

ïîìåùåíèå

Âåíòèëèðóåìîå

ïîìåùåíèå

Ïðèìåðû âåíòèëÿöèîííûõ

îòâåðñòèé äëÿ ïðèòîêà âîçäóõà

Ðèñ. À

Óâåëè÷åíèå ðàññòîÿíèÿ ìåæäó

äâåðüþ è ïîëîì.

Ðèñ. Â

Â êàìèí èëè â äûìîõîä ñ ìåäíûì ïîêðûòèåì

(äëÿ êóõîííûõ óñòðîéñòâ äëÿ ïðèãîòîâëåíèÿ

ïèùè)

Íåïîñðåäñòâåííî â

àòìîñôåðó

ñîáëþäàòü ñëåäóþùèå ìåðû ïðåäîñòîðîæíîñòè:

a) Êóõîííûå ýëåìåíòû, ðàñïîëîæåííûå ðÿäîì ñ êóõîííîé

ïëèòîé, âûñîòà êîòîðûõ ïðåâûøàåò óðîâåíü âàðî÷íîé ïàíåëè,

äîëæíû íàõîäèòüñÿ íà ðàññòîÿíèå íå ìåíåå 110 ìì îò êðàÿ

âàðî÷íîé ïàíåëè.

b) Âûòÿæêà äîëæíà áûòü óñòàíîâëåíà â ñîîòâåòñòâèè ñ

ðóêîâîäñòâîì ïî ýêñïëóàòàöèè âûòÿæêè è â ëþáîì ñëó÷àå íà

âûñîòå íå ìåíåå 650 ìì.

c) Ðàñïîëîæèòå íàâåñíûå øêàôû, ïðèëåãàþùèå ê âûòÿæêå, íà

âûñîòå íå ìåíåå 420 ìì îò ðàáî÷åé ïîâåðõíîñòè êóõíè (Ðèñ.

C).

HOOD

420

Min.

min.

650

mm. with hood

min.

700

mm. without hood

mm.

600

Min. mm.

420

Min. mm.

Ðèñ. Ñ

d) Åñëè âàðî÷íàÿ ïàíåëü óñòàíàâëèâàåòñÿ ïîä íàâåñíûì

øêàôîì, ïîñëåäíèé äîëæåí ðàñïîëàãàòüñÿ íà âûñîòå íå

ìåíåå 700 ìì îò ïîâåðõíîñòè, êàê ïîêàçàíî íà Ðèñ. Ñ.

e) Íèøà êóõîííîãî ýëåìåíòà äîëæíà èìåòü ðàçìåðû, óêàçàííûå

íà Ðèñ. D. Ïðåäóñìàòðèâàþòñÿ êðåïåæíûå êðþêè,

ïîçâîëÿþùèå êðåïèòü âàðî÷íóþ ïàíåëü íà ðàáî÷åé

ïîâåðõíîñòè êóõíè òîùèíîé îò 20 äî 40 ìì. Äëÿ íàäåæíîãî

êðåïëåíèÿ âàðî÷íîé ïàíåëè ðåêîìåíäóåòñÿ èñïîëüçîâàòü âñå

ïðèëàãàþùèåñÿ êðþêè.

555 mm

55 mm

475 mm

Ðèñ. D

Ñõåìà êðåïëåíèÿ êðþêîâ

Ïîëîæåíèå êðþêà äëÿ Ïîëîæåíèå êðþêà äëÿ

ðàáî÷åé ïîâåðõíîñòè ðàáî÷åé ïîâåðõíîñòè H=30

ìì H=40 ìì

Ñïåðåäè

Ïîëîæåíèå êðþêà äëÿ Ñçàäè

top H=20mm

ÏÐÈÌÅ×ÀÍÈÅ: Èñïîëüçóéòå êðþêè èç êîìïëåêòà

«âñïîìîãàòåëüíûå ïðèíàäëåæíîñòè»

f) Åñëè âàðî÷íàÿ ïàíåëü íå óñòàíàâëèâàåòñÿ ñâåðõó âñòðîåííîãî

äóõîâîãî øêàôà, íåîáõîäèìî âñòàâèòü äåðåâÿííóþ ïàíåëü â

êà÷åñòâå èçîëÿöèè. Ýòà ïàíåëü äîëæíà áûòü óñòàíîâëåíà íà

ðàññòîÿíèè íå ìåíåå 20 ìì îò íèæíåé ÷àñòè âàðî÷íîé ïàíåëè.

Ïðèìå÷àíèå: Åñëè âàðî÷íàÿ ïàíåëü óñòàíàâëèâàåòñÿ ñâåðõó

âñòðîåííîãî äóõîâîãî øêàôà, ðåêîìåíäóåòñÿ óñòàíîâèòü äóõîâîé

øêàô íà äâà äåðåâÿííûõ áðóñêà. Åñëè â íèøå ñïëîøíàÿ îïîðíàÿ

ïîâåðõíîñòü, â çàäíåé ñòåíêå íèøè äîëæåí èìåòüñÿ ïðîåì íå

ìåíåå 45 õ 560 ìì.

560 mm.

45 mm.

Åñëè âàðî÷íàÿ ïàíåëü óñòàíàâëèâàåòñÿ ñâåðõó âñòðîåííîãî

äóõîâîãî øêàôà, íå îñíàùåííîãî ïðèíóäèòåëüíîé îõëàäèòåëüíîé

âåíòèëÿöèåé, äëÿ íàäëåæàùåé âåíòèëÿöèè âíóòðè êóõîííîãî

ýëåìåíòà íåîáõîäèìî ïðîäåëàòü âåíòèëÿöèîííûå îòâåðñòèÿ äëÿ

öèðêóëÿöèè âîçäóõà. Ïðèìåðû âîçìîæíîãî ìîíòàæà ïîêàçàíû íà

ðèñóíêàõ íèæå.

Ïîäñîåäèíåíèå ê ãàçîïðîâîäó

Ïîäñîåäèíåíèå èçäåëèÿ ê ãàçîïðîâîäó èëè ê ãàçîâîìó áàëëîíó

äîëæíî îñóùåñòâëÿòüñÿ â ñîîòâåòñòâèè ñ äåéñòâóþùèìè

íàöèîíàëüíûè íîðìàòèâàìè è òîëüêî ïîñëå ïðîâåðêè

ñîîòâåòñòâèÿ èçäåëèÿ òèïó ãàçà, ê êîòîðîìó îí ïîäñîåäèíÿåòñÿ.

Â ñëó÷àå íåñîîòâåòñòâèÿ âûïîëíèòå îïåðàöèè, îïèñàííûå â

ïàðàãðàôå «Íàñòðîéêà íà ðàçëè÷íûå òèïû ãàçà». Â ñëó÷àå

èñïîëüçîâàíèÿ ñæèæåííîãî ãàçà èç áàëëîíà èñïîëüçîâàòü

ðåãóëÿòîðû äàâëåíèÿ, ñîîòâåòñòâóþùèå äåéñòâóþùèìè

íàöèîíàëüíûè íîðìàòèâàìè .

Âàæíî: äëÿ íàäåæíîãî ôóíêöèîíèðîâàíèÿ, ðàöèîíàëüíîãî

èñïîëüçîâàíèÿ ýíåðãèè è áîëåå äëèòåëüíîãî ñðîêà ñëóæáû

ýëåêòðè÷åñêîãî èçäåëèÿ ïðîâåðüòå, ÷òîáû äàâëåíèå ïîäà÷è ãàçà

ñîîòâåòñòâîâàëî çíà÷åíèÿì, óêàçàííûì â òàáëèöå1

«Õàðàêòåðèñòèêè ãàçîâûõ êîíôîðîê è ôîðñóíîê».

Ïîäñîåäèíåíèå ïðè ïîìîùè òâåðäîé òðóáêè (ìåäíîé èëè

ñòàëüíîé)

Ïîäñîåäèíåíèå ê ãàçîïðîâîäó íå äîëæíî îêàçûâàòü êàêèõ-ëèáî

íàãðóçîê íà èçäåëèå. Íà ïîäàþùåì ãàçîïðîâîäå èçäåëèÿ èìååòñÿ

âðàùàþùååñÿ êîëåíî ñ óïëîòíèòåëüíîé ïðîêëàäêîé. Ïðè

íåîáõîäèìîñòè ïîâåðíóòü êîëåíî îáÿçàòåëüíî íåîáõîäèìî

çàìåíèòü óïëîòíèòåëüíóþ ïðîêëàäêó (ïðèëàãàåòñÿ ê èçäåëèþ).

Ïàòðóáîê ïîäà÷è ãàçà â èçäåëèå èìååò öèëèíäðè÷åñêóþ íàðóæíóþ

ðåçüáó 1/2 ãàç.

Ïîäñîåäèíåíèå ïðè ïîìîùè ãèáêîé òðóáêè èç

íåðæàâåþùåé ñòàëè ñî ñïëîøíûìè ñòåíêàìè ñ

ðåçüáîâûìè ñîåäèíåíèÿìè.

Ïàòðóáîê ïîäà÷è ãàçà â èçäåëèå èìååò öèëèíäðè÷åñêóþ íàðóæíóþ

ðåçüáó 1/2 ãàç. Èñïîëüçóéòå òîëüêî òðóáêè è óïëîòíèòåëüíûå

ïðîêëàäêè, ñîîòâåòñòâóþùèå äåéñòâóþùèì íàöèîíàëüíûì

íîðìàòèâàì. Ïîäñîåäèíåíèå ýòèõ òðóáîê äîëæíî ïðîèçâîäèòüñÿ

òàêèì îáðàçîì, ÷òîáû èõ äëèíà ïðè ìàêñèìàëüíîì ðàñòÿæåíèè

íå ïðåâûøàëà 2000 ìì. Ïî çàâåðøåíèè ïîäñîåäèíåíèÿ

ïðîâåðèòü, ÷òîáû ìåòàëëè÷åñêàÿ ãèáêàÿ òðóáêà íå êàñàëàñü

ïîäâèæíûõ ÷àñòåé èëè íå áûëà ñæàòà.

Ïðîâåðêà óïëîòíåíèÿ

ïî çàâåðøåíèè ïîäñîåäèíåíèÿ ïðîâåðüòå ïðî÷íîñòü óïëîòíåíèÿ

âñåõ ïàòðóáêîâ ïðè ïîìîùè ìûëüíîãî ðàñòâîðà, íî íèêîãäà íå

ïëàìåíåì.

Ýëåêòðè÷åñêîå ïîäñîåäèíåíèå

Âàðî÷íûå ïàíåëè, îñíàùåííûå òðåõïîëÿðíûì ïðîâîäîì

ýëåêòðîïèòàíèÿ, ðàñ÷èòàíû íà ôóíêöèîíèðîâàíèå ñ ïåðåìåííûì

òîêîì ñ íàïðÿæåíèåì è ÷àñòîòîé ýëåêòðîïèòàíèÿ, óêàçàííûìè

íà çàâîäñêîé òàáëè÷êå ñ äàííûìè (ðàñïîëîæåííîé ñíèçó âàðî÷íîé

ïàíåëè). Ïðîâîä çàçåìëåíèÿ ïðîâîäà ýëåêòðîïèòàíèÿ

âûäåëÿåòñÿ æåëòî-çåëåíûì öâåòîì. Â ñëó÷àå óñòàíîâêè âàðî÷íîé

ïàíåëè ñâåðõó äóõîâîãî øêàôà, âñòðîåííîãî â êóõîííûé ýëåìåíò,

ýëåêòðè÷åñêîå ïîäñîåäèíåíèå âàðî÷íîé ïàíåëè è äóõîâîãî

øêàôà äîëæíî âûïîëíÿòüñÿ ðàçäåëüíî ïî ïðè÷èíàì

áåçîïàñíîñòè, à òàê æå äëÿ ëåãêîãî ñúåìà äóõîâîãî øêàôà.

Ïîäñîåäèíåíèå ïðîâîäà èçäåëèÿ ê ñåòè ýëåêòðîïèòàíèÿ

Ïîäñîåäèíèòå ê ïðîâîäó èçäåëèÿ ñòàíäàðòíóþ ýëåêòðè÷åñêóþ

âèëêó, ðàñ÷èòàííóþ íà íàãðóçêó, óêàçàííóþ íà çàâîäñêîé òàáëè÷êå

ñ äàííûìè. Â ñëó÷àå ïðÿìîãî ïîäñîåäèíåíèÿ ê ñåòè

ýëåêòðîïèòàíèÿ íåîáõîäèìî óñòàíîâèòü ìåæäó ýëåêòðîïðèáîðîì

è ñåòüþ ìíîãîïîëþñíûé âûêëþ÷àòåëü ñ ìèíèìàëüíûì

ðàññòîÿíèåì ìåæäó êîíòàêòàìè 3 ìì, ðàñ÷èòàííûé íà íàãðóçêó è

ñîîòâåòñòâóþùèé äåéñòâóþùèì íîðìàòèâàì (ïðîâîä çàçåìëåíèÿ

íå äîëæåí ïðåðûâàòüñÿ âûêëþ÷àòåëåì). Ïðîâîä ýëåêòðîïèòàíèÿ

äîëæåí ðàñïîëàãàòüñÿ òàêèì îáðàçîì, ÷òîáû íè â êàêîé òî÷êå îí

íå ïîäâåðãàëñÿ íàãðåâàíèþ, ïðåâûøàþùåìó òåìïåðàòóðó

ïîìåùåíèÿ íà 50°C.

Ïåðåä îñóùåñòâëåíèåì ýëåêòðè÷åñêîãî ïîäñîåäèíåíèÿ

íåîáõîäèìî ïðîâåðèòü ñëåäóþùåå:

 îãðàíè÷èòåëüíûé êëàïàí è äîìàøíÿÿ ñèñòåìà äîëæíû áûòü

ðàñ÷èòàíû íà íàãðóçêó èçäåëèÿ (ñìîòðèòå çàâîäñêóþ òàáëè÷êó

ñ òåõíè÷åñêèìè äàííûìè);

 Ñåòü ýëåêòðîïèòàíèÿ äîëæíà áûòü îñíàùåíà íàäåæíûì

çàçåìëåíèåì ñîãëàñíî íîðìàòèâàì è óêàçàíèÿì

çàêîíîäàòåëüñòâà;

 Ýëåêòðè÷åñêàÿ ðîçåòêà èëè ìíîãîïîëþñíûé âûêëþ÷àòåëü

äîëæíû áûòü ëåãêîäîñòóïíû áåç íåîáõîäèìîñòè ñúåìà

âàðî÷íîé ïàíåëè.

ÏÐÈÌÅ×ÀÍÈÅ: íå èñïîëüçóéòå óäëèíèòåëè, ïåðåõîäíèêè èëè

àäàïòåðû, òàê êàê îíè ìîãóò âûçâàòü ïåðåãðåâ èëè âîçãîðàíèå.

Ïîäãîòîâêà ê ðàçëè÷íûì òèïàì ãàçà

Äëÿ ïîäãîòîâêè âàðî÷íîé ïàíåëè ê òèïó ãàçà, îòëè÷àþùåìóñÿ îò

ãàçà, íà êîòîðûé âàðî÷íàÿ ïëèòà ðàñ÷èòàíà èçíà÷àëüíî (óêàçàí

íà ýòèêåòêå ñíèçó âàðî÷íîé ïàíåëè èëè íà óïàêîâêå), íåîáõîäèìî

çàìåíèòü ôîðñóíêè êîíôîðîê ñëåäóþùèì îáðàçîì:

 ñíèìèòå ñ âàðî÷íîé ïàíåëè îïîðíûå ðåøåòêè è âûíüòå

êîíôîðêè èç ñâîèõ ãíåçä.

 îòâèíòèòå ôîðñóíêè ïðè ïîìîùè ïîëîãî ãàå÷íîãî êëþ÷à 7 ìì

è çàìåíèòå èõ íà ôîðñóíêè, ðàñ÷èòàííûå íà íîâûé òèï ãàçà

(ñìîòðèòå òàáëèöó 1 «Õàðàêòåðèñòèêè êîíôîðîê è ôîðñóíîê»).

 âîññòàíîâèòü äåòàëè íà ñâîè ìåñòà, âûïîëíÿÿ îïåðàöèè â

îáðàòíîì ïîðÿäêå.

 Ïî çàâåðøåíèè îïåðàöèè çàìåíèòå ñòàðóþ ýòèêåòêó

òàðèðîâàíèÿ íà íîâóþ, ñîîòâåòñòâóþùóþ íîâîìó òèïó

èñïîëüçóåìîãî ãàçà. Ýòèêåòêó ìîæíî çàêàçàòü â íàøèõ Öåíòðàõ

Òåõíè÷åñêîãî Îáñëóæèâàíèÿ.

Åñëè äàâëåíèå èñïîëüçóåìîãî ãàçà îòëè÷àåòñÿ îò

ïðåäóñìîòðåííîãî äàâëåíèÿ (èëè âàðüèðóåò), íåîáõîäèìî

óñòàíîâèòü íà ïèòàþùåì ãàçîïðîâîäå ñîîòâåòñòâóþùèé

ðåãóëÿòîð äàâëåíèÿ ñîãëàñíî äåéñòâóþùèì íàöèîíàëüíûì

íîðìàòèâàì («Ðåãóëÿòîðû äëÿ êàíàëèçèðîâàííûõ ãàçîâ»).

Ðåãóëÿöèÿ ïåðâè÷íîãî âîçäóõà êîíôîðîê

Êîíôîðêè íå íóæäàþòñÿ â êàêîé-ëèáî ðåãóëÿöèè ïåðâè÷íîãî

âîçäóõà.

Ðåãóëÿöèÿ ìèíèìàëüíîãî ïëàìåíè

 ïîâåðíèòå ðóêîÿòêó â ïîëîæåíèå ìèíèìàëüíîãî ïëàìåíè;

 ñíèìèòå ðóêîÿòêó è ïîâåðíèòå ðåãóëÿöèîííûé âèíò,

ðàñïîëîæåííûé âíóòðè èëè ðÿäîì ñî ñòåðæíåì êðàíà, âïëîòü

äî ïîëó÷åíèÿ ñòàáèëüíîãî ìàëîãî ïëàìåíè;

ÏÐÈÌÅ×ÀÍÈÅ: â ñëó÷àå èñïîëüçîâàíèÿ ñæèæåííîãî ãàçà

âèíò ðåãóëÿöèè äîëæåí áûòü çàâèí÷åí äî óïîðà.

 ïðîâåðüòå, ÷òîáû ïðè ðåçêîì ïîâîðîòå ðóêîÿòêè èç ïîëîæåíèÿ

ìàêñèìàëüíîãî ïëàìåíè íà ìèíèìàëüíîå, êîíôîðêè íå ãàñëè.

 â èçäåëèÿõ, îñíàùåííûõ çàùèòíûì óñòðéîñòâîì (òåðìîïàðà)

â ñëó÷àå íåèñïðàâíîñòè èçäåëèÿ ñ êîíôîðêàìè ïðè

ìèíìàëüíîì ïîâûøåíèè ðàñõîäà

Ïî çàâåðøåíèè ðåãóëÿöèè óñòàíîâèòå íà ìåñòî ïëîìáû íà

îáâîäíîì ãàçîïðîâîäå

Õàðàêòåðèñòèêè ãàçîâûõ êîíôîðîê è ôîðñóíîê

* Ïðè 15°C è 1013 ìáàð  ñóõîé ãàç

** Ïðîïàí Òåïëîòâîðíàÿ ñïîñîáíîñòü = 50,37 ÌÄæ/êã

*** Áóòàí Òåïëîòâîðíàÿ ñïîñîáíîñòü = 49,47 ÌÄæ/êã

Ïðèðîäíûé ãàç Òåïëîòâîðíàÿ ñïîñîáíîñòü = 37,78 ÌÄæ/ì3

(1) Òîëüêî äëÿ èçäåëèé, îñíàùåííûõ çàùèòíûì óñòðîéñòâîì ïðîòèâ óòå÷êè ãàçà (ññûëêà F).

CISPH 640... CISPH 640MST...

Äàííîå èçäåëèå ñîîòâåòñòâóåò ñëåäóþùèì

Äèðåêòèâàì Åâðîïåéñêîãî Ñîîáùåñòâà:

- 73/23/CEE îò 19/02/73 (Íèçêîå íàïðÿæåíèå) è

ïîñëåäóþùèì èçìåíåíèÿì;

- 89/336/CEE îò 03.05.89 (Ýëåêòðîìàãíèòíàÿ

ñîâìåñòèìîñòü) è ïîñëåäóþùèì èçìåíåíèÿì;

- 90/396/CEE îò 29.06.90 (Ãàç) è ïîñëåäóþùèì

èçìåíåíèÿì;

- 93/68/CEE îò 22.07.93 è ïîñëåäóþùèì èçìåíåíèÿì.

Òàáëèöà 1

Ñæèæåííûé ãàç Ïðèðîäíûé ãàç

Kîíôîðêà Äèàìåòð

(ìì)

Òåïëîòâîðíàÿ

ñïîñîáíîñòü êÂò

(p.c.s.*)

Áàéïàñ

1/100 (ìì)

Ôîðñó-

íêà

1/100

(ìì)

Ðàñõîä*

ã/÷àñ

Ôîðñó-

íêà

1/100

(ìì)

Ðàñõîä-

* ë/÷àñ

Ôîðñó-

íêà

1/100

(ìì)

Ðàñõî-

ä* ë/÷àñ

Íîìèí. Ñîêðàù. (1) *** **

Áûñòðàÿ

(Áîëüøàÿ)(R)

100 3.00 0.70 41 39 86 218 214 116 286 143 286

Áûñòðàÿ

(ñîêðàùåííàÿ)

(RR)

100 2.60 0.70 41 39 80 189 186 110 248 135 248

Ïîëóáûñòðàÿ

(Ñðåäíÿÿ)(S)

75 1.65 0.40 30 28 64 120 118 96 157 105 157

Âñïîìîãàòåë-

üíàÿ (Ìàëàÿ)

(À)

55 1.00 0.40 30 28 50 73 71 71 95 80 95

Òðîéíàÿ (ÒÑ) 130 3.25 1.30 60 57 91 236 232 133 309 150 303

Äàâëåíèå

ïîäà÷è

Íîìèíàëüíîå (ìáàð)

Ìèíèìàëüíîå (ìáàð)

Ìàêñèìàëüíîå (ìáàð)

28-30

6,5

Indesit CISPH 640 M (IX) Guida utente

Marca: Indesit

Modello: CISPH 640 M (IX)

Tipo: Guida utente

Questo manuale è adatto anche per

Scarica il pdf

rapporto

in altre lingue

English: Indesit CISPH 640 M (IX) User guide

Indesit CISPH 640 M (IX) Guida utente

Questo manuale è adatto anche per

Indesit CISPH 640 M (IX) Guida utente

in altre lingue

Documenti correlati

Altri documenti