Model:
CD229-A / CD230-A
Refrigerated
Merchandiser
Instruction manual
2
EN Telephone Helpline: 1300225960
Safety Instructions
Please take a few moments to carefully read through this
manual. Correct maintenance and operation of this machine will
provide the best possible performance from your POLAR product.
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components or service panels on this product.
- In Queensland the service agent/qualified technician
MUST hold a Gas Work Authorisation or License for
hydrocarbon refrigerants if the appliance gas system is
being opened or charged.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT allow oil or fat to come into contact with the plastic
components or door seal. Clean immediately if contact occurs.
• DO NOT store products on top of the appliance.
• Bottles that contain a high percentage of alcohol must be
sealed and placed vertically in the refrigerator.
• Always carry, store and handle the appliance in a vertical
position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the unit
before cleaning.
• Keep all packaging away from children. Dispose of the packaging
in accordance with the regulations of local authorities.
3
EN
Telephone Helpline: 1300225960
• Children should be supervised to ensure that they do not play
with the appliance.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Polar recommend that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Caution: Risk of Fire
• Do not store explosive substances such as aerosol cans
with a flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.
• To comply with AS/NZS 60079.10.1:2009: Ensure
there are not sources of ignition in any area where
refrigerant could gather in the event of a leak.
• Electrical equipment should not be placed under the vent
or where refrigerant could gather in the event of a leak.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance.
Product Description
CD229-A - POLAR Refrigerated Display Merchandiser 120 litre
CD230-A - POLAR Refrigerated Display Merchandiser 160 litre
4
EN Telephone Helpline: 1300225960
Pack Contents
The following is included:
• POLAR Counter-Top Refrigerated Merchandiser
• Shelves x 2
• Instruction manual
POLAR prides itself on quality and service, ensuring
that at the time of unpacking the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit,
please contact your POLAR dealer immediately.
Installation
Note: Not for use in vans or trailers, food
trucks or similar vehicles.
If the unit has not been stored or moved in
an upright position, let it stand upright for
approximately 12 hours before operation.
If in doubt allow to stand.
1. Remove the appliance from the packaging.
Make sure that all protective plastic film and
coatings are thoroughly removed from all
surfaces.
2. To optimize performance and longevity, ensure
a minimum clearance of 2.5cm is maintained
between the unit and walls and other objects,
with a minimum 20cm clearance on the top.
NEVER LOCATE NEXT TO A HEAT SOURCE.
Note: Before using the appliance for the
first time, clean the shelves and interior
with soapy water then dry well.
Operation
Control Panel
The control panel is located below the doors on the
rear of the appliance.
Turn On
1. Close the doors of the appliance.
2. Connect the appliance to a mains power
supply.
3. Press the button to turn the light On or Off
as required.
Setting the Operating Temperature
1. Press the SET button. The display will flash.
2. Press the or buttons to display the
required temperature.
3. Press the SET button to store the temperature.
Manual Defrost
Press and hold the button for 6 seconds to begin
automatic defrost. The defrost light illuminates.
Cleaning, Care &
Maintenance
1. Switch off and disconnect from the power
supply before cleaning.
2. The doors can be removed for ease of
cleaning.
3. Clean the interior of the appliance as often as
possible.
4. Do not use abrasive cleaning agents. These
can leave harmful residues.
5. Clean the door seal with warm soapy water.
6. Always wipe dry after cleaning.
Condensation and ice will form with frequent
and prolonged opening of the doors.
Operating outside of the recommend
temperature range and placing next to a
heat source will also increase the amount
of ice and internal/external condensation.
If external condensation occurs wipe the
surface down with a cloth.
Excessive ice will result in longer running
times that will increase energy consumption
and increase the deterioration of
components.
Replacing the Interior Lamp
Call your POLAR dealer or a qualified electrician,
the Lamp Assembly is available to purchase as a
spare part.
5
EN
Telephone Helpline: 1300225960
Cleaning the Condenser
Periodically cleaning the condenser can extend the life of the appliance.
POLAR recommend that a POLAR agent or qualified technician clean the condenser.
Troubleshooting
A qualified technician must carry out repairs if required.
Fault Probable Cause Solution
The appliance is not
working
The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug or lead is damaged Replace plug or lead
Mains power supply fault Check mains power supply
The appliance
turns on, but the
temperature is too
high/ low
Too much ice on the condenser Defrost the appliance
Condenser blocked with dust Clean the condenser
Doors are not shut properly Check doors are shut and seals are not
damaged
Appliance is located near a heat
source, in the direct sunlight or
air flow to the condenser is being
interrupted
Move the refrigerator to a more suitable
location
Ambient temperature is too high Increase ventilation or move appliance to a
cooler position
Unsuitable foodstuffs are being
stored in the appliance
Remove any excessive hot foodstuffs or
blockages to fan
Appliance is overloaded Reduce the amount of food stored in the
appliance
The appliance is
leaking water
The appliance is not properly
levelled
Adjust the screw feet to level the appliance
(if applicable)
The appliance is
unusually loud
Loose screw/nut Check and tighten all nuts and screws
The appliance has not been installed
in a level or stable position
Check installation position and change if
necessary
The display lamp
does not illuminate
Lamp needs replacing Replace the lamp
Light not turned on Ensure Light button has been pressed
properly
Door does not shut Dirt/obstacle in runners Clean runners
Error code EE4 • Restricted Airflow
• Blocked Condenser
• Increase airflow
• Clean the condenser
6
EN Telephone Helpline: 1300225960
Technical Specifications
Note: Due to our continuing program of research and development, the specifications herein may be
subject to change without notice.
Model Voltage Power
(W)
Current
(A)
Temperature
Range
Capacity
(Ltr) Refrigerant Dimensions
H x W x D mm
Weight
(kg)
CD229-A 220-240V~
50Hz
160 1.4A 2°C to 12°C 120 R600a (50g) 686 x 696 x
568
57
CD230-A 200 1.4A 2°C to 12°C 160 R600a (65g) 686 x 874 x
568
66
Note: For optimal product performance and efficiency, please ensure to mind the net usable capacity (load
limit) when filling.
Electrical Wiring
The plug is to be connected to a suitable mains socket.
POLAR appliances are wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to
change specifications without notice.
DECLARATION OF CONFORMITY
• Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •
• Declaración de conformidad
Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp
• Tipo di apparecchiatura • Tipo de equipo
Model • Modèle • Modell • Modello
• Modelo
Countertop Refrigerated Merchandiser (Digital Controller) Black
Countertop Refrigerated Merchandiser (Digital Controller) White
Refrigerated Display Merchandiser - 120Ltr
Refrigerated Display Merchandiser - 160Ltr
CC611 (& -E -A)
CC666 (& -E -A)
CD229 (& -E -A)
CD230 (& -E -A)
Application of Territory Legislation
& Council Directives(s)
Toepassing van Europese
Richtlijn(en) • Application de la/des
directive(s) du Conseil • Anwendbare
EU-Richtlinie(n) • Applicazione delle
Direttive
• Aplicación de la(s) directiva(s) del
consejo
Low Voltage Directive (LVD) - 2014/35/EU
(BS) EN 60335-1:2012 +A11:2014 +A13:2017
+A1:2019 +A14:2019 +A2:2019
(BS) EN 60335-2-89:2010 +A1:2016 +A2:2017
(BS) EN 62233:2008
Electro-Magnetic Compatibility (EMC)
Directive 2014/30/EU - recast of 2004/108/EC
(BS) EN IEC 61000-6-1: 2019
(BS) EN IEC 61000-6-3: 2021
Eco-design energy-related products Directive
2009/125/EC; Regulation (EU)
2019/2024 - Ecodesign direct sales
refrigerators
(BS) ISO 23953-1:2015
(BS) ISO 23953-2:2015
Restriction of Hazardous Substances Directive
(RoHS) 2015/863 amending Annex II to
Directive 2011/65/EU
Electrical Safety
EN 60335-1:2012 +A11:2014 +A13:2017
+A1:2019 +A14:2019 +A2:2019EN
60335-2-89:2010 +A1:2016 +A2:2017
EN 62233:2008
Electromagnetic Compatibility
EN IEC 61000-6-1: 2019
EN IEC 61000-6-3: 2021
Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers
• Nome del produttore • Nombre del fabricante
Polar
I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s)
and Standard(s).
Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande
Richtlijn(en) en Standaard(en).
Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus
Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und
Norm(en) entspricht.
Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.
El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y
estándar(es) arriba mencionadas.
Date • Data • Date • Datum • Data •
Fecha
9th May 2023
Signature • Handtekening •
Signature • Unterschrift Firma •
Firma
Full Name • Volledige naam • Nom
et prénom • Vollständiger Name •
Nome completo • Nombre completo
Ashley Hooper
Eoghan Donnellan
Brendan Denmeade
Position • Functie • Fonction •
Position • Qualifica • Posición
Technical & Quality
Manager
Commercial
Manager/ Importer
Commercial Manager/ Responsible
Supplier
Producer Address • Adres fabrikant •
Adresse du producteur • Anschrift
des Herstellers • Indirizzo del
produttore • Dirección del fabricante
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom
Unit 9003,
Blarney Business
Park,
Blarney,
Co. Cork
Ireland
15 Bagdally Road,
Campbelltown
NSW 2560
DocuSign Envelope ID: 4E2FFA06-4BC9-42D3-8C82-E3DD695BB4A0
CD229-A_CD230-A_A5_v4_2023/05/31
http://www.polar-refrigerator.com/
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
in altre lingue
- English: Polar CD229-A User manual
- français: Polar CD229-A Manuel utilisateur