Model:
G604-A / G605-A / G606-A / G607-A
Stainless Steel Pizza
Salad Prep/Saladette
Counter
Instruction manual
2
AU Telephone Helpline: 1300225960
Safety Instructions
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components or service panels on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT stand or support yourself on the base, drawers or
doors.
• DO NOT allow oil or fat to come into contact with the plastic
components or door seal. Clean immediately if contact occurs.
• Bottles that contain a high percentage of alcohol must be
sealed and placed vertically in the refrigerator.
• Always carry, store and handle the appliance in a vertical
position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the unit
before cleaning.
• Keep all packaging away from children. Dispose of the
packaging in accordance with the regulations of local
authorities.
• If the power cord is damaged, it must be replaced by a POLAR
agent or a recommended qualified technician in order to avoid
a hazard.
3
AUAU
Telephone Helpline: 1300225960
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Polar recommend that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Caution Risk of Fire
• Do not store explosive substances such as aerosol cans with a
flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are the
type recommended by the manufacturer.
Product Description
G604-A - POLAR 2 Door Pizza/Salad Prep Counter Refrigerator
G605-A - POLAR 3 Door Pizza/Salad Prep Counter Refrigerator
G606-A - POLAR 2 Door Saladette Counter
G607-A - POLAR 3 Door Saladette Counter
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your POLAR product.
4
AU Telephone Helpline: 1300225960
Pack Contents
The following is included:
• POLAR Refrigerator
• Shelf guides
• Shelves
• Gastronorm Adaptor Bars
• Floor guards
• Instruction manual
POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR dealer immediately.
Installation
Note: If the unit has not been stored or moved in an upright position, let it stand
upright for approximately 12 hours before operation. If in doubt allow to stand.
1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are
thoroughly removed from all surfaces.
2. To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between
the unit and walls and other objects, with a minimum 5cm clearance on the top. NEVER LOCATE
NEXT TO A HEAT SOURCE.
Note: Before using the appliance for the first time, clean the shelves and interior
with soapy water.
3. Level the appliance by adjusting the screw feet.
Fitting the Shelves & Floor Guards
1. Place one set of shelf guides on either side of the cabinet at the desired height.
2. Slide the shelf into place.
3. Repeat for the remaining shelves.
4. Place the floor guards on the floor of the cabinet, ensuring the flat side is clear of the floor.
Note: This is vital for ensuring correct drainage of condensation.
5
AUAU
Telephone Helpline: 1300225960
GN Pan Layout
Model: G604-A
1/6 1/6 1/6 1/6 1/6
1/3 1/6 1/3
1/6 1/6 1/61/3
1/6 1/6 1/6 1/6 1/6
1/3 1/6 1/3
1/6 1/6 1/61/3
1/6 1/6 1/6 1/6 1/6
1/3 1/6 1/3
1/6 1/6 1/61/3
Model: G605-A
1/2
1/4
1/4
1/2 1/2
1/4
1/4
1/2 1/2 1/2 1/2
1/2
1/4
1/4 1/4
1/4
1/4
1/4 1/4
1/4 1/4
1/4
1/4
1/4
1/2
1/4
1/4 1/4
1/4
1/2
1/2
1/4
1/4
1/2 1/2
1/4
1/4
1/2 1/2 1/2 1/2
1/2
1/4
1/4 1/4
1/4
1/4
1/4 1/4
1/4 1/4
1/4
1/4
1/4
1/2
1/4
1/4 1/4
1/4
1/2
Model: G606-A
1/1
1/4
1/4
1/1
1/1
1/6
1/6
1/3
1/6
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/4
1/4
1/3
1/3
1/3
1/3
1/3
1/3 1/6
1/6
1/6
1/4
1/4
1/2
1/2
1/2
1/2
1/1
1/4 1/4
1/4
1/6
1/6
1/6
1/4
1/1
1/4
1/4
1/1
1/1
1/6
1/6
1/3
1/6
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/4
1/4
1/3
1/3
1/3
1/3
1/3
1/3 1/6
1/6
1/6
1/4
1/4
1/2
1/2
1/2
1/2
1/1
1/4 1/4
1/4
1/6
1/6
1/6
1/4
1/1
1/4
1/4
1/1 1/1
1/6
1/6
1/3
1/6
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/4
1/4
1/3
1/3
1/3
1/3
1/3
1/3 1/6
1/6
1/6
1/4
1/4
1/2
1/2
1/2
1/2
1/1
1/4 1/4
1/4
1/6
1/6
1/6
1/4
6
AU Telephone Helpline: 1300225960
Model: G607-A
1/1 1/1
1/2
1/2
1/4 1/4
1/1 1/1
1/1 1/1
1/2
1/2
1/2
1/2
1/1 1/1
1/1
1/2
1/2
1/2
1/2
1/2
1/2
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/2
1/2
1/6 1/6 1/6 1/6
1/2
1/2
1/3
1/3
1/3
1/3
1/2
1/6 1/6 1/6 1/6
1/1 1/1
1/2
1/2
1/4 1/4
1/1 1/1
1/1 1/1
1/2
1/2
1/2
1/2
1/1 1/1
1/1
1/2
1/2
1/2
1/2
1/2
1/2
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/3
1/2
1/2
1/6 1/6 1/6 1/6
1/2
1/2
1/3
1/3
1/3
1/3
1/2
1/6 1/6 1/6 1/6
Operation
Storing Food
To get the best results from your POLAR appliance,
follow these instructions:
• Only store foodstuffs in the appliance when it
has reached the correct operating temperature.
• Ensure gastronorm bays are full at all times,
even if the gastronorms are unused or empty.
Empty bays will greatly reduce efficiency of the
appliance.
• Always close the lid when not in use.
• Do not place uncovered hot food or liquid
inside the appliance.
• Wrap or cover food where possible.
• Do not obstruct the fans inside the appliance.
• Avoid opening the doors for prolonged periods
of time.
Note: The appliance is not
intended for the long term
storage of food.
Open/Close the Lid (G606-A/
G607-A Only)
The lid of the G606-A and G607-A Saladette
Counter is multi-positional:
1. With the lid closed, slide the panel back into
the half open position. This allows partial
access to the gastronorm trays.
2. Lift the lid up and back so the hinge settles
into the support slot.
3. Lift the lid up and completely back so the
gastronorm trays are completely exposed.
WARNING: The sliding lid does
not have a locking mechanism.
Always make sure that the lid
is in the ‘half-open’ position
before opening.
7
AUAU
Telephone Helpline: 1300225960
Turn On
1. Close the door(s) of the appliance.
2. Ensure the power switch is set to [O] and turn
on at the socket.
3. Switch on the Power [I]. The current
temperature within the appliance is displayed.
Control Panel
To See the Setpoint
Push and immediately release the SET key. The
display will show the setpoint value.
Changing the Setpoint
1. Press the SET button for 3 seconds. The
display will flash.
2. Press the or buttons to display the
required temperature.
3. Press the SET button to store the temperature.
Manual Defrost
The appliance will automatically run a defrost cycle
every six hours.
Note: The cycle starts from the
time the appliance is initially
powered up.
To manually defrost the appliance:
1. Press and hold the “aux” button for more than
2 seconds.
2. The defrost cycle will start immediately and the
Defrost LED illuminates.
Note: Starting a manual defrost
also resets the automatic
defrost timer.
The next automatic defrost will start six hours after
the manual defrost has finished.
Cleaning, Care &
Maintenance
Switch off and disconnect
from the power supply before
cleaning.
• Clean the interior of the appliance as often as
possible.
• Do not use abrasive cleaning agents. These
can leave harmful residues.
• Clean the door seal with warm soapy water.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run
through the drain hole into the evaporation
pan.
• Take care when cleaning the rear of the
appliance. Sharp edges can cut.
• A POLAR agent or qualified technician must
carry out repairs if required.
Note: Condensation will form
in refrigeration with frequent
opening of the doors and on
hot humid days, please ensure
condensation is allowed to drain
properly or is wiped dry.
Cleaning the Condenser Filter
• The condenser is part of the refrigeration
system. The condenser filter requires monthly
cleaning.
• Always disconnect power supply before
carrying out Routine Maintenance.
• Failure to clean the condenser filter will reduce
the performance and life of your Polar unit and
may invalidate your warranty.
• These models have a removable filter which
can be cleaned with a vacuum cleaner.
8
AU Telephone Helpline: 1300225960
Troubleshooting
If your POLAR appliance develops a fault, please check the following table before making a call to the
Helpline or your POLAR dealer.
Fault Probable Cause Solution
The appliance is
not working
The unit is not switched on Check the unit is plugged in correctly
and switched on
Plug or lead is damaged Call POLAR agent or qualified Technician
Power supply Check power supply
The appliance
turns on, but
the temperature
is too high/low
Too much ice on the evaporator Defrost the appliance
Condenser blocked with dust Clean the Condenser
Doors are not shut properly Check doors are shut and seals are not
damaged
Appliance is located near a heat source or air
flow to the condenser is being interrupted
Move the refrigerator to a more suitable
location
Ambient temperature is too high Increase ventilation or move appliance
to a cooler position
Unsuitable foodstuffs are being stored in the
appliance
Remove any excessive hot foodstuffs or
blockages to the fan
Appliance is overloaded Reduce the amount of food stored in
the appliance
The appliance is
leaking water
The appliance is not properly levelled Adjust the screw feet to level the
appliance (if applicable)
The discharge outlet is blocked Clear the discharge outlet
Movement of water to the drain is
obstructed
Clear the floor of the appliance (if
applicable)
The water container is damaged Call POLAR agent or qualified Technician
The drip tray is overflowing Empty the drip tray (if applicable)
The appliance is
unusually loud
Loose nut/screw Check and tighten all nuts and screws
The appliance has not been installed in a
level or stable position
Check installation position and change
if necessary
Technical Specifications
Model Voltage Power Current Temperature
Range Refrigerant Dimensions
H x W x D mm
Weight
(kg)
G604-A 220-240V~ 50Hz 155W 1.2A 2°C - 8°C R600a 68g 1180 x 903 x 700 70
G605-A 220-240V~ 50Hz 235W 1.3A 2°C - 8°C R600a 110g 1180 x 1370 x 700 100
G606-A 220-240V~ 50Hz 155W 1.2A 2°C - 8°C R600a 70g 882 x 900 x 700 70
G607-A 220-240V~ 50Hz 235W 1.3A 2°C - 8°C R600a 100g 882 x 1365 x 700 107
9
AUAU
Telephone Helpline: 1300225960
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
The appliances must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory standards and
specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to
change specifications without notice.
DECLARATION OF CONFORMITY
• Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •
• Declaración de conformidad • Declaração de conformidade
Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp
• Tipo di apparecchiatura • Tipo de equipo • Tipo de equipamento
Model • Modèle • Modell • Modello
• Modelo • Malli
G-Series Pizza Prep Counter Fridge 254Ltr
G-Series Pizza Prep Counter Fridge 390Ltr
G-Series Saladette Counter Fridge 240Ltr
G-Series Saladette Counter Fridge 368Ltr
G604 (& -E -A)
G605 (& -E -A)
G606 (& -E -A)
G607 (& -E -A)
Application of Territory Legislation
& Council Directives(s)
Toepassing van Europese
Richtlijn(en) • Application de la/des
directive(s) du Conseil • Anwendbare
EU-Richtlinie(n) • Applicazione delle
Direttive
• Aplicación de la(s) directiva(s) del
consejo • Aplicação de directiva(s) do
Conselho
Machinery Directive 2006/42/EC
EN 60335-1:2012 +A11:2014 +A13:2017
+A1:2019 +A14:2019 +A2:2019
EN 60335-2-89:2010 +A1:2016 +A2:2017
EN 62233:2008
Electro-Magnetic Compatibility (EMC)
Directive 2014/30/EU - recast of 2004/108/EC
EN 55014-1:2017
EN 55014-2:2015
EN 61000-3-2: 2014
EN 61000-3-3: 2013
Restriction of Hazardous Substances Directive
(RoHS) 2015/863 amending Annex II to
Directive 2011/65/EU
Electrical Safety
IEC 60335-1:2010 +A1:2013 +A2:2015
IEC 60335-2-89:2010 +A1:2012 +A2:2016
Electromagnetic Compatibility
EN 55014-1:2017
EN 55014-2:2015
EN 61000-3-2: 2014
EN 61000-3-3: 2013
Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers
• Nome del produttore • Nombre del fabricante • Nome do fabricante
Polar
I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s)
and Standard(s).
Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande
Richtlijn(en) en Standaard(en).
Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus
Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und
Norm(en) entspricht.
Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.
El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y
estándar(es) arriba mencionadas.
Eu, o abaixo-assinado, declaro que o equipamento anteriormente especificado está em conformidade com a(s) anterior(es)
Directiva(s) e Norma(s)
Date • Data • Date • Datum • Data •
Fecha • Data
7
th
January 2021
Signature • Handtekening •
Signature • Unterschrift Firma •
Firma • Assinatura
Full Name • Volledige naam • Nom
et prénom • Vollständiger Name •
Nome completo • Nombre completo
• Nome por extenso
Ashley Hooper
Eoghan Donnellan
Josie Holt
Position • Functie • Fonction •
Position • Qualifica • Posición •
Função
Technical & Quality
Manager
Commercial
Manager/ Importer
Commercial Manager/ Responsible
Supplier
Producer Address • Adres fabrikant •
Adresse du producteur • Anschrift
des Herstellers • Indirizzo del
produttore • Dirección del fabricante
• Morada do fabricante
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom
42 North Point
Business Park
New Mallow Road
Cork
Ireland
15 Bagdally Road,
Campbelltown
NSW 2560
DocuSign Envelope ID: 79C9DE56-745B-4A67-B316-FC921422B08F
G604-A_G605-A_G606-A_G607-A_A5_v6_20211015
http://www.polar-refrigerator.com/
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
